6
TABLE OF CONTENTS
SELF-DIAGNOSIS FUNCTION .................................... 2
1. SERVICING NOTES.............................................. 7
2. GENERAL .................................................................. 16
3. DISASSEMBLY ........................................................ 19
4. TEST MODE .............................................................. 32
5. ELECTRICAL ADJUSTMENTS
MD Section .................................................................... 37
CD Section ..................................................................... 47
6. DIAGRAMS
6-1. Block Diagram – MD SERVO Section – ...................... 49
6-2. Block Diagram – D/A, A/D CONVERTER Section – .. 50
6-3. Block Diagram – MAIN Section ................................... 51
6-4. Block Diagram – DISPLAY/POWER Section – ........... 52
6-5. Note for Printed Wiring Boards and
Schematic Diagrams ...................................................... 53
6-6. Printed Wiring Board – BD (CD) Board – .................... 54
6-7. Schematic Diagram – BD (CD) Board – ....................... 55
6-8. Printed Wiring Boards – CD CHANGER Section – ..... 56
6-9. Schematic Diagram – CD CHANGER Section – ......... 57
6-10. Schematic Diagram – BD (MD) Board (1/2) – ............. 58
6-11. Schematic Diagram – BD (MD) Board (2/2) – ............. 59
6-12. Printed Wiring Boards – BD (MD) Board –.................. 60
6-13. Schematic Diagram – MD DIGITAL Board (1/3) – ..... 61
6-14. Schematic Diagram
– MD DIGITAL (2/3)/RELAY Boards – ....................... 62
6-15. Schematic Diagram – MD DIGITAL Board (3/3) – ..... 63
6-16. Printed Wiring Board
– MD DIGITAL Board (Component Side) – ................ 64
6-17. Printed Wiring Boards
– MD DIGITAL (Conductor Side)/RELAY Boards – .. 65
6-18. Schematic Diagram – MAIN Board (1/2) – .................. 66
6-19. Schematic Diagram – MAIN Board (2/2) – .................. 67
6-20. Printed Wiring Board – MAIN Board – ....................... 68
6-21. Printed Wiring Board – AMP Board – .......................... 70
6-22. Schematic Diagram – AMP Board – ............................. 71
6-23. Printed Wiring Boards – JACK/JOG Boards –.............. 72
6-24. Schematic Diagram – JACK/JOG Boards – .................. 73
6-25. Schematic Diagram – PANEL Board – ........................ 74
6-26. Printed Wiring Board – PANEL Board – ...................... 75
6-27. Printed Wiring Board – REG Board – ........................... 76
6-28. Schematic Diagram – REG Board –.............................. 77
6-29. Printed Wiring Boards
– POWER/SELECTOR Boards – .................................. 78
6-30. Schematic Diagram
– POWER/SELECTOR Boards – .................................. 79
6-31. IC Pin Function Description .......................................... 83
7. EXPLODED VIEWS ............................................... 95
8. ELECTRICAL PARTS LIST .............................. 102
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be dam-
aged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C dur-
ing repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous ra-
diation exposure.
This appliance is classified as a CLASS 1 LASER product.
The CLASS 1 LASER PRODUCT MARKING is located on
the rear exterior.
Laser component in this product is capable of emitting radiation
exceeding the limit for Class 1.
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
To Next Page
Loading...
