TYM T1054 - Engine System Troubles

7 - 
TROUBLESHOOTING
1. ENGINE SySTEm
TROUBLE cAUSE AcTION
Engine system
Thestartmotordoesnotro-
tate when the main switch is
turned
Clutchpedalreleased
PTO ON/OFF switch set in ON
position
Defectivesafetyswitch
Batterydischarged
Loose terminal
Faulty switch
Defectivestartmotor
•
•
•
•
•
•
•
Depresstheclutchpedal
Set the PTO ON/OFF switch into the OFF position
Haveitrepairedorreplacedbyworkshop
Charge the battery
Checkforloosenessandcorrosion.Clean,tightenand
apply grease
Haveitrepairedorreplacedbyworkshop
Haveitrepairedorreplacedbyworkshop
•
•
•
•
•
•
•
The start motor runs but its
speedcannotbeincreased
Weak battery
Poorground
Incorrectviscosityofengineoil
•
•
•
Charge the battery
Cleanthecontactandconnectthegroundrmly
Changeengineoilwithproperviscosity
•
•
•
The start motor runs but the
enginecannotbestarted
Air in fuel system
Cloggedfuellter
No fuel supply
Defectiveengine
Defectivekeystopunit
•
•
•
•
•
Bleedthesystem
Cleanorreplacethelter
Openthecockandaddfuel
Haveitrepairedbyworkshop
Haveitrepairedbyworkshop
•
•
•
•
•
The engine runs irregularly
Air in fuel system
Cloggedfuellter
Cloggedinjectionnozzle
Fuel leak from pipe
Poorfuelinjection
•
•
•
•
•
Bleedthesystem
Cleanorreplacethelter
Haveitrepairedbyworkshop
Tighten the clamp, replace the pipe or machine the
surface of the copper washer before installation
Haveitrepairedbyworkshop
•
•
•
•
•