Westerbeke 3.5 SBCG - Software Diagnostics

SOFTWARE DIAGNOSTICS
Engine RUN State Warnings:
Engine RUN state is - DC circuit breaker on, generator successfully started and running
In the RUN state all warnings are logged and a light will be illuminated on the control panel. The light(s) will go out
when the warning condition is
no longer present. Warnings will be indicated as follows:
Oil Pressure warnings illuminate the OIL PRESSURE light.
Engine Coolant Temperature warnings illuminate the ENGINE TEMP light.
EXhaust Temperature High illuminates the EXHAUST TEMP light.
External Alarm warning illuminates the EXT. ALARM light.
OverSpeed and UnderSpeed warnings illuminate the pair of SPEED lights.
All other warnings illuminate the pair of CHECK ENGINE lights.
1 Engine
Coolant Temp Lo_w
Reading less than
o excessively cold weather
-25oc (
-13°F)
o faulty temperature sensor
2
Engine
Coolant Temp High
Reading more than
• faulty temperature sensor
95°C (203°F)
0
engine heat soak after normal shutdown
3
UnderSpeed
Under
1760 rpm for 8+
o excessive load on generator
seconds
o fuel supply insufficient
OverSpeed
Over 2375 rpm for 8+
o vacuum leak in intake manifold or hoses
4
seconds
o throttle shaft sticking
5
OverLoad
Throttle wide open and
o excessive load on generator
RPM <2200 for 8+ sec
o loose connection or corroded wiring
6
Ctank Sensor Possible Fault Internal ECU. parameter
" sensor tip contaminated with metal filings
o speed conditioning module faulty
7
Oil Pressure Sender Shorted
Short
circuit (o ohms)
o faulty oil pressure sender
or bare wire in harness
8
Oil Pressure Sender Open
Open
circuit (oo ohms)
o faulty oil pressure sender
o loose connection or corroded wiring
-Re-ading less than 12 psi
• check oil level
9
Oil Pressure Low
o insure proper oil viscosity
for 5
sec
.• check lubrication system for leaks
• blown fuse
Battery
Voltage Low
Less than 11 volts
o dead battery
10
o faulty regulator or charging circuit
• loose connection or corroded wiring
11
Battery Voltage High
More than
15 volts
o faulty regulator or charging circuit
Ambient
Air Temp Shorted
Short
circuit (o ohms)
o faulty air temperature sensor
12
o pinched or bare wire in harness
13
Ambient Air Temp Open Open circuit
• faulty air temperature sensor
o loose connection or corroded wiring
14
Ambient Air Temp Low
Reading less than
o excessively cold weather
-25°C (-13°F) air temperature sensor
Reading more than
o excessively hot weather
15
Ambient Air Temp High
9~tC (203°F)
•
bilge venting system faulty or inadequate
~ WESTERBEKE
.•.faulty sensor
Engines & Generators
33