Alba MC250 - Maintenance of the Machine; Daily Maintenance

MC250 page 47 of 78
MC250 Rev.02-USA  (+34) 944 71 16 00  (+34) 944 53 17 54  export@alba.es www.alba.es
5. MAINTENANCE OF THE MACHINE

5.1. Daily maintenance
Dailymaintenanceincludesbasicoperationsofvisualinspectioninthehoist,performedbythe
personRESPONSIBLEofthehoistonthebuilding.EVERYDAY,priortouse,visualinspectionof
theelevatorshouldbedone:
 Alltheprotectionsareinstalled,andtherearenodangerousholesorgaps.
 There´snoaccumulationofice,snoworrubbishinsidethecage,ornearthehoist.
 There´snoexcesivewearintherack,orintheverticalpipeofthemast.
 Loadinformationplateisinstalledonthecarrier.
 Zonebelowthehoistisdelimitedandprotected.
 Thereisn´tanywarpedorcrackedpart(Caseof,changeit).
 Electricalwiresarecorrectlyinstalledandtightlyguidedonthehoist.
 Guiderollersaretouchingthemasttubeandwithoutexcesivewear.
 Therearenopowerlinesnearthehoistthatendangerpeopleormachine.
 Therearenooutgoingelementsinthefacadethatmayinterferewiththemachine.
 Electricalsafetydevicesareoperational(doors,endtrackswitch,mastsensor.
 Emergencystopworksproperly.
 Anchoragesarecorrectlyinstalled.
 Rack‐piniontransmissioniscorrectlyengaged.
 Controlandpowerboardsareingoodcondition.
 Allthecontrols,panelsandindicatorsworkproperly.
 Cabletravelsandslidesoverthecableholderproperly.
Onceallthelistedcheckpointsarereviewedandtheproblemsthathaveappearedhavebeen
solved,themachinecanbesafelyused.

WARNING
Before carrying out any maintenance intervention under the machine, disconnect
the power supply and block the movement of the cabin on the rack, creating a
minimumclearanceof1.8munderthelift.
MaintenancetasksmustbeperformedWITHOUTLOADS.
