Data Aire gForce Ultra - Table of Contents

TABLE OF CONTENTS
3
INTRODUCTION ............................................................................................................................ 9
Product Information ............................................................................................................................. 9
Model Identification ........................................................................................................................... 10
Inspection .......................................................................................................................................... 10
Paperwork ......................................................................................................................................... 11
Storage.............................................................................................................................................. 11
Suggested Reference Storage Room Conditions ....................................................................... 11
General Storage Considerations ................................................................................................ 12
Registered Trademarks – Copy Rights – References Section ........................................................... 12
INSTALLATION ........................................................................................................................... 13
Recommended Tools for Installation ................................................................................................. 14
Pre-Installation .................................................................................................................................. 14
Installation must be planned so that: ................................................................................................. 14
Room Considerations ........................................................................................................................ 15
Equipment Handling and Rigging ...................................................................................................... 15
Door and Rear Panel Removal ................................................................................................... 16
Rear Panel ................................................................................................................................. 17
Moving Unit into Final Location ................................................................................................... 17
Rigging .............................................................................................................................................. 18
Locating the Unit ............................................................................................................................... 19
Downflow Units .................................................................................................................................. 19
Upflow Units ...................................................................................................................................... 20
Piping ................................................................................................................................................ 21
Air-cooled Unit Piping ........................................................................................................................ 22
Discharge Lines ................................................................................................................................. 22
Liquid Lines ....................................................................................................................................... 24
Recommended Line Sizing, Air-cooled Units ..................................................................................... 24
Connection Sizes, Air-cooled Units .................................................................................................... 25
Field Piping, Remote Condenser Above Evaporator .......................................................................... 26
Field Piping, Remote Condenser Below Evaporator .......................................................................... 27
Refrigerant Piping Protection ............................................................................................................. 28
Water/Glycol Cooled Unit Piping ........................................................................................................ 29
Factory Charge for Water/Glycol Cooled System ............................................................................... 30
Connection Sizes, Water/Glycol Cooled Units ................................................................................... 30
Field Piping, Water/Glycol System ..................................................................................................... 31
Connection Sizes, Fluid Coolers (Dry Coolers) .................................................................................. 32
Auxiliary Chilled Water/Energy Saver Coil Piping .............................................................................. 32
Condensate Drain System ................................................................................................................. 32
Condensate Trap ........................................................................................................................ 33
Auxiliary Chilled Water/Energy Saver Coil Piping .............................................................................. 35
Humidifier Piping ............................................................................................................................... 35
Steam Generator Humidifier ....................................................................................................... 35
Leak Testing ...................................................................................................................................... 35
Electrical Installation .......................................................................................................................... 36
Commissioning Information ............................................................................................................... 36