GREENLINE 40 - Page 49

To Next Page

To Previous Page

Greenline 40

WARNING!

When using the platform (UP or DOWN) make sure that platform is

free of any obstacles.

Do not stand on the platform while operating the platform.

When closing: do not put any subjects between the platform and the

hull!

Max load on the platform is 150 kg

Main Page

Table of Contents3
Introduction8
Specification & Warranties11
Specification11
Figure 1: Boat Main Dimensions13
Warranty Guidelines14
Figure 2: Boat Examination Report16
Figure 3: Engine Examination Certificate (CMD TDI 75-4)17
Figure 4: Engine Examination Certificate ( CMD TDI 150-5)18
Figure 5: Engine Examination Certificate (CMD TDI V6)19
Figure 6: Declaration of Conformity20
Builder's Plate22
Figure 7: Builders Certificate Plate22
Registration Details23
Commissioning Distributor23
Safety24
Life Raft Storage24
Figure 8: Liferaft Storage Location24
Safety Equipment25
Man Overboard Prevention and Recovery26
Figure 9: Working Deck Area Plan26
Lpg System27
Figure 10: LPG System27
Safety Directions Concerning Gas Stove28
Figure 11: Gas Shut off Valve Position28
Fight against Fire & Emergency Exits31
Figure 12: Emergency Exits31
Figure 13: Fire Extinguishers Position32
Figure 14: Automatic Extinguisher Piping Mounted on Engine Room Hatch32
Bilge Stripping35
Figure 15: Table of Symbols35
Figure 16: Automatic Bilge Pump with Automatic Switch36
Figure 17: Manual Bilge Pump with Integral Handle in Cockpit37
Figure 18: Bilge Pump System Plan37
Hull39
Through Hull Fittings39
Figure 19: Thru Hull Fitting Positions39
Figure 20: Engine Seawater Inlet40
Figure 21: Hybrid Cooling Pump Seawater Inlet40
Figure 22: Marine Head & Chain Wash down Inlet, Sump Box Outlet, Black Water Tank Outlet40
Figure 23: Manual Bilge Outlet, Galley Sink Outlet, Hybrid Cooling Pump Outlet, Automatic Bilge Outlet40
Seacock41
Hull Maintenance41
Dry Docking42
Gel-Coat Repairs Instruction42
Deck44
Deck Layout44
Figure 24: Deck Layout44
Mooring45
Towage45
Anchoring46
Figure 25: Anchor Winch with Chain Stopper46
Radar47
Swimming Platform47
Figure 26: Manual Switch for El. Platform48
Figure 27: Latch on the Platform48
Deck Maintenance50
Accomodations51
Maintenance51
Figure 28: Accomodations51
Fabrics52
Plumbing54
Figure 29: Sea Water Plumbing54
Figure 30: Fresh Water Plumbing55
Figure 31: Grey Water Plumbing56
Water Tank Filling57
Figure 32: Black Water Plumbing57
Figure 33: WATER Deck Filler on PORT Side58
Fresh Water System59
Figure 34: Fresh Water Pump with Boiler59
Toilet Operation60
Figure 35: Marine Head with Control Panel and Black Water Gauge60
Figure 36: Sea Water System Position61
Figure 37: Sea Water Inlet Valve61
Figure 38: Sea Water Pump61
Figure 39: Solenoid Valve for Marine Head61
Gas System62
Water Discharge62
Figure 41: Black Water Outlet Position62
Figure 42: Black Water Outlet Valve62
Figure 43: Sump Box Position63
Figure 44: Sump Box63
Figure 45: Sump Box Outlet Valve Position63
Figure 46: Sump Box Outlet Valve63
Sanitary Appliance Operation65
Electrical System66
Arriving on the Boat66
Picture 3: 24H CONSUMERS on the Right Side; 230Vac CONSUMERS on the Left Side67
SELECTING ELECTRIC or DIESEL DRIVE68
Hybrid Data Display Interface - DDI71
Battery Monitoring - Bmv72
Phoenix Multi Control Inverter / Charger73
Picture 5: Phoenix Multi Control74
Solar Panels77
Technical Room77
Parallel Switch78
Switches79
Fuses80
Picture 10: Location of AC/DC Panel81
Picture 12: Main AC/DC Power Box86
Picture 14: Mooring Box Fuses87
Picture 16: Shore Power Fuse88
Picture 18: Hybrid Box Fuses89
Power Sources90
Picture 21: Kitchen 230V Sockets91
Shore Power92
Air Condition Additional Shore Power93
Batteries94
Maintenance and Additional Warnings94
Lipo BATTERY BANK - WINTER STORAGE97
Engine & Steering Gear101
Engines101
Figure 47: Twin Engine with Hybrid Drive101
Figure 48: Engine Seawater Inlet with Water Strainer102
Engine Operation103
Ventilation System103
Determination of Maximum Propulsion Power Rating103
Figure 49: Engine Compartment Air Intake103
Figure 50: Engine Compartment Air Outlet with Exhaust Blower103
Dash Board / Control Lever104
Visibility in the Steering Station104
Figure 51: Engine Control Lever104
Propellers105
Anode105
Figure 52: Propellers and Anodes105
Fuel System106
Figure 53: Fuel System106
Fuel Tank107
Figure 54: FUEL Deck Filler on PORT Side107
Fuel Filter108
Figure 55: Fuel Pre-Filter with Valve on Supply Line108
Fuel109
Steering109
Figure 56: Steering System110
Figure 57: Steering System with Rudders110
Launching111
Launching Hints111
Figure 58: Position of Hoisting Cradle and Straps112
Laying up and Winter Precautions113
Laying up113
Protection and Mainteinance113
APPENDIX A: Wiring Diagrams115
APPENDIX B: Consumer Locations124
Ig Error Listing129
Ac Error Listing130
Notes134

GREENLINE 40 - Page 49

Table of Contents

Related product manuals