GREENLINE 40 - Figure 17: Manual Bilge Pump with Integral Handle in Cockpit; Figure 18: Bilge Pump System Plan

137 pages

Save Page as PDF

To Next Page

To Previous Page

Greenline 40

Figure 17: Manual bilge pump with integral handle in cockpit

Figure 18: Bilge pump system plan

Main Page

Table of Contents3
Introduction8
Specification & Warranties11
Specification11
Figure 1: Boat Main Dimensions13
Warranty Guidelines14
Figure 2: Boat Examination Report16
Figure 3: Engine Examination Certificate (CMD TDI 75-4)17
Figure 4: Engine Examination Certificate ( CMD TDI 150-5)18
Figure 5: Engine Examination Certificate (CMD TDI V6)19
Figure 6: Declaration of Conformity20
Builder's Plate22
Figure 7: Builders Certificate Plate22
Registration Details23
Commissioning Distributor23
Safety24
Life Raft Storage24
Figure 8: Liferaft Storage Location24
Safety Equipment25
Man Overboard Prevention and Recovery26
Figure 9: Working Deck Area Plan26
Lpg System27
Figure 10: LPG System27
Safety Directions Concerning Gas Stove28
Figure 11: Gas Shut off Valve Position28
Fight against Fire & Emergency Exits31
Figure 12: Emergency Exits31
Figure 13: Fire Extinguishers Position32
Figure 14: Automatic Extinguisher Piping Mounted on Engine Room Hatch32
Bilge Stripping35
Figure 15: Table of Symbols35
Figure 16: Automatic Bilge Pump with Automatic Switch36
Figure 17: Manual Bilge Pump with Integral Handle in Cockpit37
Figure 18: Bilge Pump System Plan37
Hull39
Through Hull Fittings39
Figure 19: Thru Hull Fitting Positions39
Figure 20: Engine Seawater Inlet40
Figure 21: Hybrid Cooling Pump Seawater Inlet40
Figure 22: Marine Head & Chain Wash down Inlet, Sump Box Outlet, Black Water Tank Outlet40
Figure 23: Manual Bilge Outlet, Galley Sink Outlet, Hybrid Cooling Pump Outlet, Automatic Bilge Outlet40
Seacock41
Hull Maintenance41
Dry Docking42
Gel-Coat Repairs Instruction42
Deck44
Deck Layout44
Figure 24: Deck Layout44
Mooring45
Towage45
Anchoring46
Figure 25: Anchor Winch with Chain Stopper46
Radar47
Swimming Platform47
Figure 26: Manual Switch for El. Platform48
Figure 27: Latch on the Platform48
Deck Maintenance50
Accomodations51
Maintenance51
Figure 28: Accomodations51
Fabrics52
Plumbing54
Figure 29: Sea Water Plumbing54
Figure 30: Fresh Water Plumbing55
Figure 31: Grey Water Plumbing56
Water Tank Filling57
Figure 32: Black Water Plumbing57
Figure 33: WATER Deck Filler on PORT Side58
Fresh Water System59
Figure 34: Fresh Water Pump with Boiler59
Toilet Operation60
Figure 35: Marine Head with Control Panel and Black Water Gauge60
Figure 36: Sea Water System Position61
Figure 37: Sea Water Inlet Valve61
Figure 38: Sea Water Pump61
Figure 39: Solenoid Valve for Marine Head61
Gas System62
Water Discharge62
Figure 41: Black Water Outlet Position62
Figure 42: Black Water Outlet Valve62
Figure 43: Sump Box Position63
Figure 44: Sump Box63
Figure 45: Sump Box Outlet Valve Position63
Figure 46: Sump Box Outlet Valve63
Sanitary Appliance Operation65
Electrical System66
Arriving on the Boat66
Picture 3: 24H CONSUMERS on the Right Side; 230Vac CONSUMERS on the Left Side67
SELECTING ELECTRIC or DIESEL DRIVE68
Hybrid Data Display Interface - DDI71
Battery Monitoring - Bmv72
Phoenix Multi Control Inverter / Charger73
Picture 5: Phoenix Multi Control74
Solar Panels77
Technical Room77
Parallel Switch78
Switches79
Fuses80
Picture 10: Location of AC/DC Panel81
Picture 12: Main AC/DC Power Box86
Picture 14: Mooring Box Fuses87
Picture 16: Shore Power Fuse88
Picture 18: Hybrid Box Fuses89
Power Sources90
Picture 21: Kitchen 230V Sockets91
Shore Power92
Air Condition Additional Shore Power93
Batteries94
Maintenance and Additional Warnings94
Lipo BATTERY BANK - WINTER STORAGE97
Engine & Steering Gear101
Engines101
Figure 47: Twin Engine with Hybrid Drive101
Figure 48: Engine Seawater Inlet with Water Strainer102
Engine Operation103
Ventilation System103
Determination of Maximum Propulsion Power Rating103
Figure 49: Engine Compartment Air Intake103
Figure 50: Engine Compartment Air Outlet with Exhaust Blower103
Dash Board / Control Lever104
Visibility in the Steering Station104
Figure 51: Engine Control Lever104
Propellers105
Anode105
Figure 52: Propellers and Anodes105
Fuel System106
Figure 53: Fuel System106
Fuel Tank107
Figure 54: FUEL Deck Filler on PORT Side107
Fuel Filter108
Figure 55: Fuel Pre-Filter with Valve on Supply Line108
Fuel109
Steering109
Figure 56: Steering System110
Figure 57: Steering System with Rudders110
Launching111
Launching Hints111
Figure 58: Position of Hoisting Cradle and Straps112
Laying up and Winter Precautions113
Laying up113
Protection and Mainteinance113
APPENDIX A: Wiring Diagrams115
APPENDIX B: Consumer Locations124
Ig Error Listing129
Ac Error Listing130
Notes134

GREENLINE 40 - Figure 17: Manual Bilge Pump with Integral Handle in Cockpit; Figure 18: Bilge Pump System Plan

Table of Contents

Related product manuals