90-8M0069751 eng APRIL 2012 Page iii
Engine Coupler................................................................. 94
Driveshaft Extension Models............................................ 94
Sterndrive, Bellows, and Engine Alignment...................... 95
Maintaining Torques................................................................ 97
Alpha Gimbal Ring Clamp Bolt......................................... 97
Bravo Gimbal Ring U‑bolt Nuts......................................... 97
Engine Mounts.................................................................. 98
Propellers................................................................................. 98
Alpha Propeller Removal.................................................. 98
Alpha Propeller Installation............................................... 99
Bravo Diesel Sterndrive Propeller Removal..................... 99
Bravo One Models...................................................... 100
Bravo Two Models...................................................... 100
Bravo Three Models................................................... 101
Bravo Diesel Sterndrive Propeller Installation................ 102
Bravo One Models...................................................... 102
Bravo Two Models...................................................... 103
Bravo Three................................................................ 104
Drive Belts.............................................................................. 105
QSD 2.0 Drive Belts........................................................ 105
Power‑Assisted Steering Pump Belt Inspection............. 106
Serpentine Belt Inspection.............................................. 106
Battery.................................................................................... 107
Battery Precautions for Multiple Engines......................... 107
Section 6 - Storage
Cold‑Weather, Seasonal, and Extended Storage.................. 110
Cold Weather (Freezing Temperature), Seasonal Storage,
and Extended Storage.................................................... 110
Cold Weather (Freezing Temperature) Storage............. 110
Preparing Your Power Package for Seasonal or Extended
Storage........................................................................... 111
Seasonal Storage Instructions........................................ 111
Extended Storage Instructions........................................ 112
Battery............................................................................ 112
Recommissioning................................................................... 112
Section 7 - Troubleshooting
Diagnosing Electronically Controlled Fuel System Problems 116
Troubleshooting Charts.......................................................... 116
Starter Motor Will Not Crank Engine, or Cranks Slow.... 116
Engine Will Not Start, or Is Hard to Start........................ 116
Engine Runs Rough, Misses, or Backfires..................... 116
Poor Performance........................................................... 117
Incorrect Engine Temperature........................................ 117
Low Engine Oil Pressure................................................ 117
Battery Will Not Charge.................................................. 117
Remote Control Operates Hard, Binds, Has Excessive
Free‑play, or Makes Unusual Sounds............................ 118
Steering Wheel Turns Hard or Jerky.............................. 118
Power Trim does not Operate (Electric Motor Operates but
Sterndrive does not Move).............................................. 118
Power Trim Does Not Operate (Electric Motor Does Not
Operate).......................................................................... 118
Section 8 - Customer Assistance Information
Owner Service Assistance..................................................... 120
Local Repair Service........................................................ 120
Service Away From Home................................................120
Stolen Power Package..................................................... 120
Attention Required After Submersion............................... 120
Replacement Service Parts.............................................. 120
Parts and Accessories Inquiries....................................... 120
Resolving a Problem........................................................ 120
Customer Service Literature.................................................. 121
English Language............................................................ 121
Other Languages..............................................................121
Andre sprog...................................................................... 121
Andere talen..................................................................... 121
Muut kielet........................................................................ 121
Autres langues................................................................. 121
Andere Sprachen............................................................. 121
Altre lingue....................................................................... 121
Andre språk...................................................................... 121
Outros Idiomas................................................................. 121
Otros idiomas................................................................... 122
Andra språk...................................................................... 122
Allej glþssej...................................................................... 122
Ordering Literature................................................................. 122
United States and Canada............................................... 122
Outside the United States and Canada............................ 122
To Next Page
Loading...
Need help?
General