Misonix sonastar SYSTEM-M200 - Figure 3-1 Sonastar Ultrasonic Surgical Aspiration System

73 pages

Save Page as PDF

To Next Page

To Previous Page

Instructions for Use SonaStar Ultrasonic Surgical Aspiration System

IFU-601 Rev T March 2023 Page 22 of 73

Figure 3-1: SonaStar Ultrasonic Surgical Aspiration System

Main Page

Table of Contents2
Operating Safety Precautions5
General5
Conventions: Warnings, Cautions, and Notes5
Safety: Recommendations for the Use of this Device5
Figure 1-1 Sonastar Ultrasonic Surgical Aspiration System13
Handling of Handpieces14
Explosion and Fire Hazard14
High Voltage Hazard14
Power Receptacle and Plug14
Grounding the Unit14
Using the Proper Fuse15
Standards, Classifications and Symbols Used15
Installation19
Space Requirements19
Environmental Limitations19
Figure 2-1 Top View Dimensions19
Electrical Requirements20
Unpacking and Inspection20
Equipment List20
System Description21
Surgical Indications21
Contradictions21
Ultrasonic Theory21
System Overview22
Figure 3-1 Sonastar Ultrasonic Surgical Aspiration System23
Vibration System24
Irrigation System24
3.7 Aspiration System25
3.8 Wireless Footswitch25
Figure 3-2 Wireless Footswitch25
Figure 3-3 Wireless Footswitch with Integrated IR Receivers on Console Top and Left26
Controls, Indicators and Connections27
Overall System27
Figure 4-1 Top / Side View Features27
Figure 4-2 Lower Rear View28
Front Panel29
Figure 4-3 Control Panel Features29
Figure 4-4 Remote IR Receiver31
Components Rear View: Controls & Indicators32
Figure 4-5 Rear View Details32
Figure 4-6 Lower Rear View Details32
Wireless Indicators34
Figure 4-7 Low Battery and Footswitch Activation LED(S)34
Figure 4-8 Integrated IR Receiver and Remote IR Receiver34
Figure 4-9 Wireless Footswitch35
Figure 4-10 Matching Wireless Footswitch and Receiver Frequency Codes35
Handpieces36
General36
Handpiece Types36
Figure 5-1 (A) Curved Extended (CE) and (B) Short Straight (SS) Handpieces36
Handpiece Assembly37
Figure 5-2 Placing SS & CE Handpieces in the Counter Wrench38
Figure 5-3 Exploded View of CE Handpiece Parts39
Figure 5-4 CE Housing Tip Assembly39
Figure 5-5A Exploded View of SS Handpiece Parts40
Figure 5-5B Exploded View of SS Handpiece Parts with Long Curved Probe40
Figure 5-5C Exploded View of SS Handpiece Parts with Pricision, Micro and Standard Long Curved40
Figure 5-5D Exploded View of SS Handpiece Parts with Deep Access Probe40
Electrosurgery Connector Assembly41
Figure 5-6 Handpiece with Monopolar Cable Connections41
System Operating Instructions42
Pre-Operative Preparation42
Handpiece Preparation43
Preparing the Sonastar for Use45
Figure 6-1 Open Irrigation Pump Gate46
Figure 6-2 Routing of Irrigation Tubing46
System Setup47
Operative Use49
Monopolar Coag Guidelines51
Background51
Figure 7-1 Console with Force 2 Electrosurgical Generator51
Figure 7-2 Monopolar COAG Interface Schematic52
Preparing the System for Monopolar COAG Use53
Figure 7-3 Force2 Rear Connections53
Figure 7-4 Monopolar Handpiece Cable Attached to Endcap Receptacle54
Using Monopolar COAG with the System55
Figure 7-5 Force2 Front Connections55
Cleaning, Sterilization and Maintenance57
General Information57
Cleaning Procedures57
Sterilization60
Service & Repair Information61
Routine Maintenance61
Periodic Maintenance61
8.7 Fuse Replacement62
Moving the Unit62
Warranty Information62
Figure 8-1 External Filter Installed62
Figure 8-2 Internal Filter Assembly62
Troubleshooting63
9.1 Clearing Faults63
9.2 Overriding Faults63
Specifications66
Ultrasonic Surgical Aspirator Generator66
Footswitch/Remote IR Receiver69
10.3 Fuse Requirements70
UL Classification70
10.5 Accessories71
10.6 Important Notice72

Misonix sonastar SYSTEM-M200 - Figure 3-1 Sonastar Ultrasonic Surgical Aspiration System

Table of Contents

Related product manuals