Nibe FIGHTER 1240 - List of Components

List of components
FIGHTER 1240
54
1 Miniature circuit-breaker
2 EBV-card, Load monitor card
3 Thermostat, standby mode
4 Collector, brine in (f)
5 Collector, brine out (r)
6 Terminal block, pumps, shuttle valve
7 Service connection, high pressure
8 Switch, 1—0 –
9 Terminal block, incoming electricity, -X9
10 Contactor, immersion heater step 1
11 Starting capacitor, compressor
12 Start relay
14 Operating condenser, compressor
15 * Outdoor temperature sensor
16 Heating medium pump
17 Evaporator
18 Condenser
19 Reversing valve, heating system/water heater
24 Electric element
25 Temperature limiter
26 Motor protection
27 Compressor
29 Relay card with power supply unit
32 Display unit
33 High pressure pressostat
34 CPU-unit, control system
35 Brine pump
41 Low pressure pressostat
42 Service connection, low pressure
48 Expansion valve
52 * Safety valve, collector side
58 Anode cover (enamel)
60 EMC-filter
61 Suppression capacitor
63 * Particle filter (KB) R25 female
65 Drying filter
67 Contactor, immersion heater step 2
68 Contactor
69 Contactor
70 Connection, heating flow ø 22 mm o.d.
71 Connection, heating return ø 22 mm o.d.
72 Hot water circulation (VVC)
Enamel: G 20
Stainless steel: Ø 15 mm o.d.
73 Cold water
Copper: Ø 22 mm o.d.
Stainless steel: Ø 22 mm o.d.
Enamel: G 20
74 Hot water
Copper: Ø 22 mm o.d.
Stainless steel: Ø 22 mm o.d.
Enamel: G 20
75 Venting valve, double jacket
76 Drainage for heating system
77 Venting valve, collector system
81 * Particle filter (VB) R20 female.
85 * Level vessel, connection to system, R25 male
86 Temperature sensor, KB-f, brine in
87 Temperature sensor, KB-r, brine out
88 Temperature sensor, hot water jacket
89
Temperature sensor, VB-Flow, flow
94 Temperature sensor, VB-r, return
95 Type plate/serial number
96 Type plate, cooling section
97 Soft-start relay
99 Cable gland, incoming electricity
100 Knob, setting Fuse
101 Knob, setting Max electrical output
102 Knob, setting Max boiler temperature
110 Temperature sensor, hot gas
111 Temperature sensor, fluid pipe
112 Temperature sensor, suction gas
115 Electric anode (enamel)
116 Power unit, electric anode (enamel)
141 Temperature sensor, condensor heat medium
142 Temperature sensor, upper part of the hot
water heater
153 ** Compressorheater
222 Terminal block X222 for compressor heater
* Enclosed
** Only FIGHTER 1240-10, -12 3x400 V
The component list refers to all types of the heat
pump, see respective component placement pictures
for information.