Piper Cherokee Six - Page 93

25.
Inspect
air induction
system
for leaks,
security
and damage;
repair
or replace
as required.........................................
26.
Remove
air
filter
and tap
gently
to
remove
dirt
particles
(Replace
as
required)
........................................
27.
Drain
carburetor
and clean
inlet
line
fuel strainer
or clean
fuel
injector
inlet
line
strainer
(Clean
injector
nozzles
as required)
(Clean
with
acetone
only)
................................
28.
Inspect
condition
and
operation
of
carburetor
or injector
alternate
air
door
and
box
(Refer
to
the
latest
revision
of
Piper
Service
Bulletin
No.
524
and see
Note
13)
...........
...........
29.
Inspect
primer
lines
for
leaks
and
security
of mounting
.................
30. Inspect
intake
seals
for
leaks
and clamps
for
tightness
..................
31. Inspect
all
induction
air
and
alternate
heat
ducts
(Refer
to
the
latest
revision
of
Piper
Service
Bulletin
No.
356)
....................
32.
Inspect
condition
of
flexible
fuel
lines
................................
33.
Replace
flexible
fuel
lines
...........................................
34.
Inspect
fuel
system
for
leaks
.........................................
35.
Inspect
vent
lines
for evidence
of
fuel or
oil leakage:
if present,
inspect
fuel
pump
(See Note
16) .....................
.......
36.
Inspect
fuel
pumps
for
operation
(engine
driven
and electric)
............
37.
Overhaul
or
replace
fuel
pumps
(engine
driven)
(See
N o te 7) .....................
......
...... ...
38.
Inspect
operation
of
vacuum
pump
and
security
of lines
................
39.
Overhaul
or
replace
vacuum
pump
(See
Note
7)
.......................
40. Inspect
throttle.
alternate
air,
mixture
and
propeller
governor
controls
for
security,
proper
travel
and
operating
condition
(Refer
to
the
latest
revision
of Piper
Service
Bulletins
Nos.
448
and
537.
and
Piper
Service
Letter
No. 747)
........................
41.
Inspect
exhaust
stacks,
connections
and
gaskets
(Refer
to
Section
III)
Replace
gaskets
as
required...............................
42.
Inspect
muffler,
heat
exchanger
and
baffles
(Refer
to Section
III)
(Refer
to the
latest
revision
of
Piper
Service
Bulletin
No.
520)
..........
43.
Inspect
breather
tube
for obstructions
and
security
.....................
44.
Inspect
crankcase
for
security
of
seam
bolts
...........................
45. Inspect
engine
mounts
for cracks
and
loose
mountings
..................
46. Inspect
engine
baffles
for damage
and
security
of
attachments
...........
O
0
0
0
0
0
0
0
0
O
O
O
O
O
O
O
O
O
O
O
O
PIPER
CHEROKEE
SIX
SERVICE
MANUAL
TABLE
III-I.
INSPECTION
REPORT
(PA-32-260
and
300)
(cont)
Inspection
Time
(hrs)
Nature
of Inspection
50
100
500
1000
B. ENGINE
GROUP
(cont.)
O
0
O
0
O
0
O 0
O 0
O 0
O 0
O O
O 0
O
0
0
O
0
0
O 0 0
O
0
0
O
O
O
O
O
C
C
C
C
O
O
O
O O
O O
O
O
O O
INSPECTION
Revised:
12/15/80
1D21