Piper Cherokee Six - Page 94

47.
Inspect
rubber
engine
mount
bushings
for
deterioration
(Replace
as
required)
.......................................................
48.
Inspect
condition
of
fire
wall
seals
...................................
49.
Inspect
condition
and
tension
of
alternator
drive
belt
...................
50.
Lubricate
alternator
idler
pulley
(if
installed);
remove
front
grease
seal
and
add
grease
(Refer
to
lubrication
chart
in
Service
Manual,
Section
II)
51.
Inspect
condition
of
alternator
and
starter.............................
52.
Inspect
security
of alternator
mounting
...............................
53. Inspect
engine
mounted
accessories,
such
as
pumps,
temperature
and
pressure
sensing
units
for
security
of
mounting
and
tight
connections
.............................................
54.
Check
fluid
in
brake
reservoir
(Fill
as required)
........................
55.
Install
and
lubricate
all
power
plant
controls
..........................
56.
Check
air conditioning
compressor
oil
level
(See
Note
9) ................
57.
Inspect
condition
of compressor
drive
belt
and
tension
(See
Section
XIII).................................................
58. Inspect
compressor
clutch
security
and
wiring
(See
Note
10) .............
59.
Inspect
security
of
compressor
mounting
..............................
60.
Overhaul
or replace
propeller
governor*
..............................
61. Complete
overhaul
of
engine
or
replace
with
factory
rebuilt
unit
(See
Note
7) ..................................................
62.
Reinstall
engine
cowling
............................................
PIPER
CHEROKEE
SIX SERVICE
MANUAL
TABLE
III-1.
INSPECTION
REPORT
(PA-32-260
and
300)
(cont)
Nature
of Inspection
Inspection
Time
(hrs)
50
100
500
1000
B.
ENGINE
GROUP
(cont.)
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
C.
CABIN
GROUP
1.
Inspect
cabin
entrance
doors
and windows
for
damage,
operation
and
security
(See
Note
21)
..............................................
2. Inspect
upholstery
for tears
.........................................
3. Inspect
seats,
seat
belts,
security
brackets
and
bolts.....................
4. Inspect
trim
operation
(See
Note
18)
.................................
5.
Inspect
operation
of
rudder
pedals
...................................
6. Inspect
parking
brake
and
brake
handle
for
operation
and
cylinder
leaks......................................................
7. Inspect
condition
of
control
wheels,
column,
pulleys
and
cables
..........
8. Inspect
flap control
cable
attachment
bolt
(Refer
to
the
latest
revision
of Piper
Service
Bulletin
No. 597)
............................
*
(Refer
to
latest
revision
of Hartzell
S/L
No. 61)
Revised: 8/3/81
1D
22
0 0
0
0 0
0
0
0
0
0 0
0
0 0
0
0
0
0
0 0
0
0 0
INSPECTION