2
2.13
9924871 R03 - 2014 Polaris Sportsman® 570 EFI Service Manual
© Copyright 2013 Polaris Sales Inc.
Air Filter/Pre-Filter Service
It is recommended that the air filter and pre filter be
replaced annually. When riding in extremely dusty
conditions, replacement is required more often.
The pre filter should be inspected before each ride, and if
required, cleaned using the following procedure:
1. Lift up on the rear of the seat.
2. Pull the seat back and free of the tabs.
NOTE: When reinstalling seat, make sure the
slots in the seat engage the tabs in the fuel tank.
3. Remove clips (1) from air box cover and remove
cover (2). Inspect the gasket. It should adhere tightly
to the cover and seal all the way around.
4. Loosen clamp (1) and remove air filter assembly.
Cleaning:
5. Slip the pre-filter element (1) off of main element .
Clean the pre filter with hot, soapy water.
6. Rinse and dry thoroughly.
7. Inspect element for tears or damage.
8. Inspect main filter and replace if necessary. If the
filter has been soaked with fuel or oil it must be
replaced.
Installation:
9. Reinstall pre-filter element over main filter. Be sure
the element covers entire surface of main filter
without folds, creases, or gaps.
MAINTENANCE
To Next Page
Loading...
