Page 14 of 49 Instructions/Parts list Multi-Dumper MCE400 updated: 04.2021
Before any use
Read this manual.
Before each start-up, the following must be checked:
• Charge level of the battery, recharge if necessary
• Remove any dirt from the machine
• Care must be taken to ensure that the work area is free of other persons and children
• Remove obstacles from the work area. Know and mark the location of the utility lines on site.
• Check all parts, screws, brackets and equipment of the machine for correct seating, functionality
and condition.
• A check of the machine, its attachments and the functional test is necessary before each use.
Charging
IMPORTANT:
If possible, the batteries should be recharged after each use and when not in use every 2-3
weeks.
The MCE400 is supplied with maintenance-free lead batteries. These deliver a total voltage of 24V
(series connection) and have a capacity of 80-110Ah. Furthermore, the MCE400 is delivered with a
charger integrated in the control box, so that the charging process is limited to plugging the main plug
into the socket (100V-240V 50/60Hz AC voltage).
Before you connect the machine to the main plug, switch it off using the key switch and make sure that
the machine is secured against unintentional sliding / rolling. In addition, make sure that the protruding
cable does not create a "trip hazard" that could cause injuries to third parties.
Make sure that the device is connected to a properly earthed socket.
First use
The batteries are delivered with storage voltage.
DANGER! Although this voltage is sufficient for operation, the machine should still be fully charged
before commissioning! This usually takes 12 to a maximum of 15 hours.
Charging after each use
The batteries must be FULLY CHARGED after each use. This is essential to achieve a long service life.
Storage
When storing the batteries, ensure that they are kept in a dry, warm, and clean environment. The storage
temperature should be between 1 ° C and a maximum of 40 ° C. We recommend storing the batteries
only when they are fully charged and, if necessary, recharge them.
To Next Page
Loading...