Suzuki AN400 - Page 17

Table of Contents 1- i
1
Section 1
CONTENTS
Engine
Precautions ................................................. 1-*
Precautions.............................................................. 1-*
Precautions for Engine........................................... 1-*
Engine General Information and
Diagnosis ..................................................1A-*
General Description ............................................. 1A-*
Injection Timing Description .................................1A-*
Self-Diagnosis Function .......................................1A-*
Schematic and Routing Diagram........................ 1A-*
FI System Wiring Diagram ...................................1A-*
Terminal Alignment of ECM Coupler (Harness
Side)...................................................................1A-*
Component Location ........................................... 1A-*
FI System Parts Location.....................................1A-*
Diagnostic Information and Procedures............ 1A-*
Engine Symptom Diagnosis .................................1A-*
DTC Table............................................................1A-*
Fail-Safe Function Table......................................1A-*
FI System Troubleshooting ..................................1A-*
Self-Diagnostic Procedures .................................1A-*
Self-Diagnosis Reset Procedures ........................1A-*
Use of SDS Diagnostic Procedures .....................1A-*
Use of SDS Diagnosis Reset Procedures............1A-*
Show Data When Trouble (Displaying Data at
the Time of DTC) ...............................................1A-*
SDS Check ..........................................................1A-*
Malfunction Code and Defective Condition
Table ..................................................................1A-*
DTC “C12” (P0335): CKP Sensor Circuit
Malfunction.........................................................1A-*
DTC “C13” (P0105-H/L): IAP Sensor Circuit
Malfunction.........................................................1A-*
DTC “C14” (P0120/H/L): TP Sensor Circuit
Malfunction.........................................................1A-*
DTC “C15” (P0115-H/L): ECT Sensor Circuit
Malfunction.........................................................1A-*
DTC “C16” (P0500): Speed Sensor .....................1A-*
DTC “C21” (P0110-H/L): IAT Sensor Circuit
Malfunction.........................................................1A-*
DTC “C23” (P1651-H/L): TO Sensor Circuit
Malfunction.........................................................1A-*
DTC “C24” (P0351): Ignition System
Malfunction.........................................................1A-*
DTC “C28” (P1655): Secondary Throttle
Valve Actuator (STVA) Malfunction................... 1A-*
DTC “C29” (P1654-H/L): Secondary Throttle
Position Sensor (STPS) .................................... 1A-*
DTC “C32” (P0201): Fuel Injector Circuit
Malfunction........................................................ 1A-*
DTC “C40” (P0505, P0506 or P0507): ISC
Valve Circuit Malfunction................................... 1A-*
DTC “C41” (P0230-H/L): FP Relay Circuit
Malfunction........................................................ 1A-*
DTC “42” (P1650): IG Switch Circuit
Malfunction........................................................ 1A-*
DTC “C44” (P0130, P0135): HO2 Sensor
(HO2S) Circuit Malfunction ............................... 1A-*
Specifications....................................................... 1A-*
Service Data........................................................ 1A-*
Special Tools and Equipment ............................. 1A-*
Special Tool ........................................................ 1A-*
Emission Control Devices .......................1B-*
Precautions........................................................... 1B-*
Precautions for Emission Control Devices .......... 1B-*
General Description ............................................. 1B-*
Fuel Injection System Description....................... 1B-*
Crankcase Emission Control System
Description ........................................................ 1B-*
Exhaust Emission Control System
Description ........................................................ 1B-*
Noise Emission Control System Description....... 1B-*
Repair Instructions .............................................. 1B-*
Heated Oxygen Sensor (HO2S) Removal and
Installation ......................................................... 1B-*
Heated Oxygen Sensor (HO2S) Inspection ........ 1B-*
PCV Hose Inspection .......................................... 1B-*
PCV Hose Removal and Installation ................... 1B-*
Specifications....................................................... 1B-*
Service Data........................................................ 1B-*
Tightening Torque Specifications........................ 1B-*
Special Tools and Equipment ............................. 1B-*
Special Tool ........................................................ 1B-*
Engine Electrical Devices ........................1C-*
Precautions........................................................... 1C-*
Precautions for Engine Electrical Device ............ 1C-*
NOTE
For the items with asterisk (*) in the “CONTENTS” below, refer to the same section of the service manual
mentioned in the “FOREWORD” of this manual.