Takeuchi TL220 User Manual

OPERATION
Operating in Cold Weather
Preparing for Cold Weather
In cold weather, it may be difficult to start the
engine
and the coolant may freeze. Make the
preparations described below.
Changing the Fuel and Lubricant
Change the fuel , hydraulic oil and engine oil
to types suited for cold conditions.
Refer to page 108, "Lubricant
and Fuel
Chart."
Engine Coolant
AwARNING
The coolant is combustible. Keep flames
away.
Use long-life coolant (antifreeze) and tap
water for the engine coolant.
Supplement: New machines are delivered
with JIS
Type 2 long-life coolant (antifreeze)
at a concentration of 50%.
Refer to page 108, "Lubricant
and Fuel
Chart."
Battery
As the temperature drops, the battery
performance decreases.
Inspect the battery. If the charge
is low,
contact a Takeuchi dealer to have the battery
charged.
Refer to page 132, "Inspecting the Battery
Fluid Level and Replenishing."
95
Cautions after Completing
Operations
Heed the following to prevent dirt, water, or
other objects being stuck
on the machine as
well as the lower chassis from freezing:
• Remove any dirt or water from the
chassis.
In particular, water droplets on the
hydraulic cylinder rod surfaces could
freeze, and if dirt and ice enter into the
seals, the seals could break.
• Park the machine
on a dry, hard surface.
If no appropriate place can be found, put
boards down and park
on the boards.
•
Drain any water from the fuel tank to
prevent freezing.
Refer to page 134, "Draining the Fuel
Tank ."
•
To prevent decreased battery
performance, place a cover over the
battery or remove it from the machine and
store it
in a warm place.
Also add battery fluid before starting the
next morning. If battery fluid
is added after
completing operations, the distilled water
may not mix, resulting
in freezing.
After Cold Weather is Over
Perform the following after cold weather is
over:
• Change the fuel and the oils for those
specified
on the Fuel and Lubricant
Chart.
Refer to page 108, "Lubricant and
Fuel
Chart."
• When using one-season type antifreeze
coolant, completely drain the antifreeze
coolant, carefully clean the inside of the
coolant system, then add tap water.
Refer to page 144, "Cleaning the Engine
Cooling System."

Takeuchi TL220 Specifications

General

Brand	Takeuchi
Model	TL220
Category	Compact Loader
Language	English