Thomas 1700 - Page 166

5
5-25
TROUBLE SHOOTING 5.13
Problem Cause Corrective Action Section
CHARGING SYSTEM
Battery low in
charge.
Faulty wiring or con-
nections.
Check and repair or replace.
Defective alternator or
regulator.
Defective alternator or
regulator.
Defective alternator or
regulator.
Check charging output. Repair or replace if necessary.
(see Kubota manual Thomas p / n 40916)
Check charging output. Replace if necessary.
(see Kubota repair manual Thomas p / n 40916)
Check charging output. Replace if necessary.
(see Kubota repair manual Thomas p / n 40916)
Check charging output. Replace if necessary.
(see Kubota repair manual Thomas p / n 40916)
7
Defective battery.
Defective battery.
Alternator overcharg-
ing and battery over-
heats.
Test battery and replace if necessary.
Test battery and replace if necessary.
Defective regulator
Drive belt slipping.Low or no output
voltage from alterna-
tor.
Check and adjust.
Check and adjust.
Check and adjust.
7
7
Faulty wiring or con-
nections.
Check and repair or replace.
Check and repair or replace.
Check and repair or replace.
Check and repair or replace.
(see Kubota repair manual Thomas p / n 40916)
Charge indicator
light flickers or runs
dim.
Faulty wiring or con-
nections.
Dirty alternator slip
rings or brushes.
Charge indicator
goes out but becomes
brighter as the engine
RPM increases.
Faulty wiring or con-
nections.
Charge indicator
light is on while the
engine is operating.
Drive belt slipping.
Drive belt slipping.
5.6
Kubota repair
manual
Kubota repair
manual
Kubota repair
manual
Kubota repair
manual
Kubota repair
manual