Trane IntelliPak 2 Series - Dimensional Data and Clearance Requirements

220 pages

To Next Page

To Previous Page

RT-SVX24Q-EN

Water Connection Locations

Figure 14. Evaporative condenser water connection locations

RIGHT SIDE VIEW

DDiimmeennssiioonnaall DDaattaa

Main Page

Table of Contents4
Model Number Description7
General Information10
- Unit Nameplate10
- Compressor Nameplate10
- Unit Description10
Pre-Installation24
- Unit Inspection24
- Storage24
- Unit Clearances24
- Unit Dimensions and Weight25
- Information25
- Installation Checklist25
Dimensional Data28
- Water Connection Locations37
- Electrical Entry Details38
- Minimum Required Clearance39
Weights40
Installation43
- Roof Curb and Ductwork43
- Unit Rigging and Placement47
- General Installation Requirements60
Gas Heat60
Hot Water Heat61
Steam Heat61
O/A Pressure Sensor and Tubing61
Installation61
Condensate Drain Connections61
Units with Gas Furnace61
Removing Compressor Assembly61
Shipping Hardware61
Removing Supply and Exhaust Fan Shipping Channels61
Remove Evaporative Condenser Fan62
Shipping Brackets62
Installation63
Evaporative-Cooled Condenser Make-Up Water and Drain Line64
Installation65
Gas Heat Units65
General Coil Piping and Connection Recommendations69
Disconnect Switch with External72
Handle72
Electric Heat Units73
Main Unit Power Wiring73
Electrical Service Sizing76
Field Installed Control Wiring80
Controls Using 24 VAC80
Outputs80
Controls81
Variable Air Volume System81
Constant Volume or Variable Air Volume System Controls81
Single Zone Variable Air Volume & Rapid Restart System Control82
Emergency Override82
Ventilation Override Module83
(Vom)83
Coefficient84
Emergency Stop Input84
Demand Limit Relay85
- Outside Air Sensor85
- (Baysens016*)85
- System85
External Stop Input85
Occupied/Unoccupied Contacts85
Unit Startup92
- Sequence of Operation92
- Performance Data115
- Components155
- Compressor Startup171
  - Refrigerant Charging172
  - Heaters173
- Compressor Operational Sounds173
- Electronic Compressor Protection173
- Module (CPM)173
- Evaporative Condenser Startup176
Trane Startup Checklist186
- Changeover Map187
Service and Maintenance189
- Fan Belt Adjustment195
- Scroll Compressor Replacement196
- Monthly Maintenance203
- Filters203
- Cooling Season203
- Heating Season204
- Coil Cleaning205
  - Refrigerant Coils205
  - Steam or Hot Water Coils205
- Evaporative Condenser Coil Cleaning - Sump Water Management206
- Microchannel Condenser Coil Repair and Replacement207
- Final Process207
Unit Wiring Diagram Numbers210
Warranty and Liability Clause216
- Accessories216

Trane IntelliPak 2 Series - Dimensional Data and Clearance Requirements

Table of Contents

Related product manuals