pg. 52
VOLCON BRAT OWNER’S MANUAL
WARNING: FAILURE TO PROPERLY CHARGE, STORE OR USE THE BATTERY
WILL VOID YOUR WARRANTY.
Battery Maintenance & Storage
WARNING: ALL LITHIUM BATTERIES HAVE A TECHNICAL STANDARD
FOR THEIR ELECTRIC CONSUMPTION DURING STORAGE. FOLLOW THESE
INSTRUCTIONS FOR SAFE STORAGE & USE.
How to optimize your battery
• Make sure that the battery is completely exhausted when you use the battery
for the rst time after fully charging the battery. Then charge it fully again and
repeat this process two or three times to ensure that the actual capacity of the
battery is consistent with the displayed capacity.
• Always store the battery at an ambient temperature of 32°F-77°F (0°C-25°C).
Do not store the battery in an environment higher than 104°F (40°C) or below
freezing 32°F (0°C); otherwise, the battery will experience irreversible capacity
attenuation.
• Do not leave your battery exposed to high temperatures or direct sunlight for
long
periods.
• Ensure that the battery power is no less than 30% when you stop riding. If the
battery level is below 30% charge the battery to at least 50% before storing the
e-bike, this will prolong the battery life during storage.
• Do not store a discharged battery. It could go into deep discharge which will
reduce
its life.
• Over time, there may be a slight deviation between the actual capacity of the
battery and the displayed capacity.
• Discharge and recharge the battery regularly (At least once every 3 months).
The internal battery management system will automatically calibrate the
individual cells to improve your experience.
• Make sure to check the power plug connections on the battery and the
controller every two months for carbon deposition and oxidation blackening. Do
not insert metal objects into those connections.
• All batteries should be stored with a battery percentage of no less than 50%.
• Long periods of inactivity with the battery stored in the vehicle (without
disconnecting the battery), the safe storage period will be 1 month at most.
• If the battery is stored for longer than a month connected to the vehicle,
excessive battery depletion may occur that cannot be repaired.
MAINTENANCE
To Next Page
Loading...