VOLCON BRAT - Troubleshooting Common Issues; Problem Resolution Guide

VOLCON BRAT OWNER’S MANUAL
pg. 61
Problem Potential Cause Troubleshooting
Turn the power on,
but the vehicle has no
power
1) No power to the
Vehicle
2) Battery has a low
state of charge
1) Check battery switch power
is on
2) Check that the power is
connected properly, and the
battery is fully seated and locked
in place
3) Battery under voltage. Charge
the battery
Turn the power on and
twist the throttle, and
the motor does not
engage.
1) The vehicle brakes
are engaged
2) Start switch failure
1) Check that the brake handle is
not in the braking state
2) Refer to the “Operating
Instructions” section of this
Owner’s Manual (pg. 36)
3) Check the start switch
4) Contact the service department
Insufcient mileage
(reduced range)
1) Low battery
2) Insufcient tire
pressure
3) Frequent brake/start
or overloading
4) Battery aging or
normal electric quantity
decay
5) Low ambient
temperature or reduced
battery capacity
1) Check the charger for damage
2) Check the tire pressure before
use
3) Develop good driving habits
4) Replace the battery
5) This is normal
The battery will not
charge
1) The charger plug is
not connected properly
2) The battery
temperature is too high
3) The battery
temperature is too low
1) Check the charger plug, and
make sure the connections are
not loose
2) Wait for the battery to recover
to a normal temperature
Table 5 - Troubleshooting
TROUBLESHOOTING