Airo A Series - Page 5

Use and Maintenance Manual – A12 JE A15 JE A17 JE A12 JED A15 JED Series
Page 5
7.2.7.1. Pressure relief valve of proportional movement circuit .............................................................................................. 65
7.2.7.2. Pressure relief valve of ON-OFF movement circuit .................................................................................................... 66
7.2.8. Operation check of the turret inclinometer ................................................................................................................. 67
7.2.9. Adjustment of the overload controller (load cell) ........................................................................................................ 69
7.2.10. Overload controller by-pass – ONLY FOR EMERGENCY OPERATIONS ................................................................ 70
7.2.11. Operation check of M1 microswitches ....................................................................................................................... 71
7.2.12. Operation check of microswitches MPT1-MPT2 for A12 JE - A12 JED - A15 JE - A15 JED ..................................... 72
7.2.13. Operation check of MPT1-MPT2 microswitches and PS1A-PS1B proximity sensors for A17 JE .............................. 73
7.2.14. Operation check of dead-man pedal safety system ................................................................................................... 75
7.3. Battery ...................................................................................................................................................................... 75
7.3.1. General instructions for battery .................................................................................................................................. 75
7.3.2. Battery maintenance .................................................................................................................................................. 76
7.3.2.1. Accessing the battery compartment ........................................................................................................................... 76
7.3.2.2. Closing the battery compartment ............................................................................................................................... 77
7.3.2.3. Battery maintenance .................................................................................................................................................. 77
7.3.3. Battery recharge ........................................................................................................................................................ 77
7.3.4. Battery charger: fault report ....................................................................................................................................... 79
7.3.5. Battery replacement ................................................................................................................................................... 79
8. MARKS AND CERTIFICATIONS ............................................................................................................... 80
9. PLATES AND STICKERS .......................................................................................................................... 81
10. CHECK REGISTER ................................................................................................................................... 83
11. WIRING DIAGRAM .................................................................................................................................. 101
12. HYDRAULIC DIAGRAM .......................................................................................................................... 110
13. DECLARATION OF CONFORMITY......................................................................................................... 112