POSI-TRACK 2800 & 2810
PAGE 49
ASV, INC.
PROBLEM CAUSE REMEDY
Vehicle won’t 1. Battery cables loose 1. Tighten or clean cables
turn over or corroded.
2. Drive levers 2. Put levers in neutral
are not in neutral
Vehicle turns over 1. Out of fuel or 1. Add more fuel
but will not start fuel pick-up may not and bleed fuel system
be in fuel if parked on a hill
2. Pinched fuel line 2. Find and correct
3. Load on engine from 3. Put lever in neutral
High or Low flow auxiliary lever
being engaged
4. Fuel solenoid is not opening 4. Refer to electrical
trouble shooting guide
5. Plugged fuel filter 5. Change filter
6. Cold weather – need 6. Refer to
starting aid. Engine manual
Vehicle starts but 1. Low-flow auxiliary 1. Put lever in neutral
engine runs rough hydraulic lever is engaged
2. High-flow auxiliary 2. Put lever in neutral
hydraulic lever is engaged
Vehicle starts but 1. Operator not seated in seat 1. Sit down & fasten
tracks won’t go seat belt.
2. Defective seat switch 2. Refer to electrical
trouble shooting guide
3. Defective solenoid 3. Refer to electrical
trouble shooting guide
4. Low charge pressure 4. Contact dealer
Under heavy load 1. Tracks have broken traction 1. Reduce load or put more
or in loose material power to the inside track
vehicle won’t turn 2. Oil going to drive motor 2. Reduce load. Increase
is going over the relief valve power to inside track
TROUBLE SHOOTING (GENERAL)
SECTION
6
To Next Page
Loading...
Need help?
General
