34
MAINTENANCE (Cont’d)
CPS® recommends replacing the oil with fresh CPS® brand Premium Vacuum Pump Oil when:
• Oil becomes contaminated (condensation, particles) or is discolored.
• A 100 hour run time break-in period has been reached.
• NOT RUNNING the pump for an extended time.
• Vacuum pump level is significantly higher than the rated blank-off vacuum.
• When pump no longer reaches a desired vacuum level (test with a vacuum gauge attached directly on the pump).
• Depending on your oil type, application, and possible contaminants acquired when servicing A/C systems,
oil change frequency may range from daily to monthly.
CAUTION: DO NOT RUN THIS MX MACHINE WITH LOW OR NO OIL. RUNNING THIS EQUIPMENT WITH NO OR
IMPROPER OIL WILL CAUSE PREMATURE FAILURE.
VACUUM PUMP OIL CHANGE (FREQUENCY)
OIL CHANGE PROCEDURE
PRO-SET® PREMIUM VACUUM PUMP OIL
1. Before draining the Vacuum Pump Oil from an MX Series machine, ensure oil is warmed up. If not, run pump
for 10 minutes. Then, before draining oil, allow oil to reach room temperature.
If in doubt as to the temperature, use an infrared thermometer to check the housing temperature.
2. Turn MX Machine OFF then REMOVE POWER CORD FROM OUTLET.
3. Place MX Machine series pump over a suitable container for draining oil.
4. Remove Oil Drain CAP, then remove Oil Drain PLUG from drain port. AVOID CONTACT WITH HOT OIL. HOUSING
COMPONENTS MAY BE HOT. Let contaminated oil drain into suitable container. Reinstall OIL DRAIN PLUG.
5. Add fresh Pro-Set Premium Vacuum Pump Oil (by CPS) until level is between the MAX and MIN lines on
the pump housing.
Pro-Set® Premium Vacuum Pump Oil is an extremely high quality,
severely hydro-treated vacuum pump oil and can be used in pumps
made by most manufacturers.
Vacuum pump oil should always be clean and free of contaminants
such as moisture, acids, vapors, dirt etc., to extend the life of your pump.
So, replace the oil at the appropriate interval with Pro-Set Premium
Vacuum Pump oil (available in pints, quarts and gallons).
VPOG6
(1 Gallon, 6/Case)
VPOQ12 (1 Quart, 12/Case)
VPOP12 (1 Pint, 12/Case)
VPOG (1 Gallon)
VPOQ (1 Quart)
VPOP (1 Pint)
To Next Page
Loading...