GREEN INSTRUMENTS G16 - Figure 5-5: Installation of the Control and Monitoring Unit

46 pages

To Next Page

To Previous Page

G16 Smoke Density Monitor

Ver.2.4 – Revision March 2022 21

Figure 5-5: Installation of the control and monitoring unit

Main Page

Table of Contents3
Contents3
Introduction6
About this Manual6
Inquiries and Feedback7
About the System7
System Components7
Optional Components8
Specifications9
Safety Aspects11
Control at Delivery13
Installation14
In General14
Standard Installation15
Figure 5-1: Installation of the Figure 5-2: Mounting of a Support and Alignment Bracket16
Welding Sockets - Pre-Alignment17
Support and Alignment Brackets (Optional)17
Air Modules, Transceiver and Reflector18
Audit Module18
Figure 5-3: Mounting of Air18
Purge Air System19
Figure 5-4: Mounting of Air19
Control and Monitoring Unit20
Junction Box (Optional)20
Figure 5-5: Installation of the Control and Monitoring Unit21
Figure 5-6: Installation of the Figure 6-1: Transceiveri22
Electrical Connections23
Control and Monitoring Unit23
Junction Box (Optional)23
Cable Types23
Menu Structure & Configuration24
Transceiver24
Transceiver Button Function24
Figure 6-2: Illustration of Strong Signal24
Set Laser Aligning Function25
Figure 6-3: Illustration of Weak Signal25
Set Unit Address26
Figure 6-4: Illustration of Poor and Good Alignment26
Save New Settings27
Figure 6-5: Transceivera27
Calibration28
Control and Monitoring Unit28
Figure 6-6: the Automatics28
Figure 6-7: Automatics28
Home Menu29
Figure 6-8: Home Menu with29
Figure 6-9: Home Menu with29
Sensor Menu30
Alarm List Menu30
Figure 6-10: Alarm List Menu31
Figure 6-11: Select Ana31
Figure 6-12: Alarm Infos32
Trend Menu34
Sensor Setup34
Figure 6-13: Trend Menu34
Figure 6-14: Passwordp35
Figure 6-15: Sensor Setup35
System Setup36
Figure 6-16: System Setup37
Calibration38
Zero Calibration38
Auto Span Calibration38
Span Calibration38
Commissioning40
Start of the System40
Calibration40
Setting of Alarm Levels40
Setting of Signal Outputs40
Maintenance41
Troubleshooting42
Spare Parts43

GREEN INSTRUMENTS G16 - Figure 5-5: Installation of the Control and Monitoring Unit

Table of Contents