33
Measures in summer
In summer, water in the electrolyte is easy to
evaporate, therefore, electrolyte must often be
inspected if electrolyte is low, you must add
distilled water to the level appointed.
CAUTION
Do not over fill distilled water. Spilt
electrolyte will cause corrosion and
electricity leakage.
Measures in winter
– Keep effective and good surrounding for
charging.
– When it is cold, pull out the storage
battery pin to prevent discharging.
– Take measures such as covering storage
battery for warmth.
– Don’t park the truck in cold outdoor or cold
storage for a long time.
– Charge in time after work.
5.1.2 Safety precautions for using
lithium battery
1) Users need to create a file for lithium
batteries in order to better maintain the
lithium battery.
2) The new factory battery should not be
discharged, it must be fully charged
before use.
3) Lithium batteries have a special charger,
may not be charged with other types of
battery charger, so as not to charge
lithium batteries.
4) Do not open the lithium battery cover
maintenance, lithium battery failure, timely
contact with the manufacturer.
5) The battery is not used at a loss of power.
To ensure the battery life, should avoid
the discharge depth of more than 80% of
the rated capacity of the battery. Whether
it is partially discharged or fully
discharged, the battery should be
immediately charged.
6) Do not operate the lithium battery vehicle
in a temperature exceeding 55 ℃. When
the ambient temperature is below 0 ℃,
please stop charging the lithium battery
vehicle.
7) It is strictly prohibited to discharge the
battery below the termination voltage,
please charge it in time after discharge.
Avoid overcharging when charging.
8) The battery inspection and maintenance
operations, to be wearing working clothes,
wearing gloves, non-wearing watches,
metal bracelets, necklaces and other
accessories. The electrolyte inside the
battery is highly corrosive and must be
worn during operation.
9) Under no circumstances shall the battery
be shorted to the positive and negative
terminals, and any metal or other
conductive objects other than the battery
post clamping bolt and the conductive
tape should be avoided from touching the
positive and negative terminals of the
battery.
10) Do not hit, throw or trample on the battery,
do not heat the battery, do not throw the
battery into the water.
11) Do not reverse charge the battery, a
To Next Page
Loading...
