TM3160F,TM3200F&TM3240F
74
Engine
Problem Possible Cause Remedy
Starter motor does not operate
with key turned to START
• Shift lever not in neutral
• PTO shift lever engaged
• Mid PTO shift lever engaged
• Broken safety switch
• Discharged battery
• Loose or dirty terminals
• Broken main switch
• Broken starter
• PTO switch is not in off.
Place lever in neutral
Place lever in neutral
Place lever in neutral
Consult your Dealer
Charge battery
Clean and retighten securely
Consult your Dealer
Consult your Dealer
Turn PTO switch to off
Starter motor operates
but not at full speed
• Discharged battery
• Loose or dirty terminals
• Defective ground
• Improper oil viscosity
• Defective engine
Charge battery
Clean and retighten securely
Clean and tighten starter mounting
Replace with oil of proper viscosity
Consult your Dealer
Starter motor operates
but engine does not start
• Electric fuel control not operating
• Air in fuel system
• Clogged fuel filter
• Fuel is not being supplied
• Incorrect preheating procedure
• Defective engine
Consult your Dealer
Air-bleed fuel system
Clean filter
Check fuel level, open fuel valve
Increase use of glow plugs
Consult your Dealer
Irregular engine running • Air in fuel system
• Clogged fuel filter
• Clogged fuel injectors
• Fuel-line is leaking air
• Fuel injection pump timing
• Defective engine
Air-bleed fuel system
Clean filter
Consult your Dealer
Retighten clamps, replace
defective pipes
Consult your Dealer
Consult your Dealer
When decelerated, engine stops • Incorrect low idle setting
• Malfunctioning fuel injection pump
• Improper valve clearance
• Defective fuel injectors
Consult your Dealer
Consult your Dealer
Consult your Dealer
Consult your Dealer
Engine over-speeds • Defective governor
• Incorrect high speed setting
Consult your Dealer
Consult your Dealer
TROUBLESHOOTING
To Next Page
