TM3160F,TM3200F&TM3240F
76
Problem Possible Cause Remedy
Charging monitor is lit during
operation
• Defective wiring
short circuit, poor ground, etc.
• Defective alternator
• Defective regulator
• Low electrolyte level or
defective battery
• Loose or damaged fan belt
Correct loose or dirty terminals,
Consult your Dealer
Consult your Dealer
Coreect electrolyte level
or replace battery
Adjust belt tension or replace
Problem Possible Cause Remedy
Clutch slips
Clutch won't disengage
• Poor clutch pedal adjustment
• Worn or burnt clutch lining
• Engine, transmission oil leak
• Poor pedal adjustment
• Seized clutch lining
• Transmission shafts seized
Adjust free-play
Consult your Dealer
Consult your Dealer
Adjust free-play
Consult your Dealer
Consult your Dealer
Problem Possible Cause Remedy
Brakes do not work well or
not balanced with each other
when applied
• Too much free play of pedals
• Worn or seized linings
• Unequal pedal adjustment
Adjust free-play
Consult your Dealer
Correct so both pedals are equal
Problem Possible Cause Remedy
Insufficient oil pressure • Low engine speed
• Low transmission oil
• Intake piping is sucking air
• Clogged oil filer (s)
• Defective hydraulic oil pump
• Defective control valve
• Broken cylinder
Increases speed
Fill to specified level
Retighten clamps or replace cracked
pipes and defective O-rings
Clean or replace
Consult your Dealer
Consult your Dealer
Consult your Dealer
Clutch
Brakes
Hydraulic System
To Next Page
