Mauldin 1860 - Change Engine Coolant; Change Engine Fuel Filters; Change Engine Air Filter; Clean Engine Radiator Fins and Screen

40
Calder Brothers Corp
V 1.0
Model: 1860 Paver
SN:
Serial Number Range:
874-S-86TCX5Y2*03874 to _____________
6.7.2 Change Engine Coolant
1. Prepare paver for inspections and maintenance. See Section 6.2 Prepare For Inspections And Maintenance.
2. Wear personal protective equipment appropriate for the task.
3. Refer to OEM engine manufacturers’ manual for coolant specications.
4. To change coolant rst be sure engine is cool then drain coolant completely. Drain valve is located at bottom
of radiator.
5. Remove radiator cap and add coolant until full. Install cap and close access door.
6.7.3 Change Engine Fuel Filters
1. Prepare paver for inspections and maintenance. See Section 6.2 Prepare For Inspections And Maintenance.
2. Wear personal protective equipment appropriate for the task.
3. Refer to OEM engine manufacturers’ manual for fuel lter specications.
4. Both lters can be reached from the left side access door.
5. Remove fuel lter and fuel/water separator.
6. Add clean fuel to new lters.
7. Install each lter until seal contacts ange. Tighten an additional 1/2 to 3/4 turn by hand. Do not over tighten.
6.5.4 Change Engine Air Filter
1. Prepare paver for inspections and maintenance. See Section 6.2 Prepare For Inspections And Maintenance.
2. Wear personal protective equipment appropriate for the task.
3. Refer to OEM engine manufacturers’ manual for air lter specications.
4. Open air lter housing and remove lter element.
5. Clean inside of housing and end cap with a damp rag.
6. Insert new lter element and install end cap.
6.7.5 Clean Engine Radiator Fins And Screen
1. Prepare paver for inspections and maintenance. See Section 6.2 Prepare For Inspections And Maintenance.
2. Wear personal protective equipment appropriate for the task.
3. Check engine radiator ns and intake screen and for dirt and debris. Clean with low pressure compressed
air or spray wash if required.
6.7.6 Battery
^ WARNING
Batteries, battery posts, battery terminals, and related accessories can expose you to chemicals
including lead and lead compounds, which are known to the State of California to cause cancer
and birth defects or other reproductive harm.
For more information go to www.P65Warnings.ca.gov