Pierce Enforcer - Appendix A. Mobile Radio Installation Guide; Appendix B. Exterior Care of Your Vehicle; Exterior Care of Your Vehicle; B-1.1 FINISHED SURFACES of the VEHICLE

© 2020 Pierce Manufacturing Inc. All Rights Reserved. Scheduled Inspections / 7-7
LUBRICATION AND MAINTENANCE INTERVALS
7-1.8 Vendor Component Inspections
Additional Information
• See the Pierce Service Manual, group 0152-P-004, TAK-4™ Maintenance, Inspection, and Troubleshooting, for
additional front TAK-4™ suspension service and lubrication requirements.
• See the Pierce Service Manual, group 0201-P-001 (TAK-4®) or 0201-P-002 (TAK-4® T3) Maintenance,
Inspection, and Troubleshooting, for additional rear TAK-4 rear suspension service and lubrication
requirements.
• See the Pierce Service Manual, group 0611-P-001, All Steer II
®
Service Manual, for additional All Steer II
®
service and lubrication requirements.
Annual Preventative Maintenance, Checks, and Services
System/Component Action
Standard
Interval
Alternate
As Indicated
Air Dryer Desiccant Replace desiccant.
See Air Dryer
Manual
Air Dryer Rebuild air drier including desiccant cartridge
See Air Dryer
Manual
Axle, Rear Replace lubricant (initial drain and fill).
See Axle
Manual
Axle, Rear Replace oil & oil filter (if applicable) in carrier.
See Axle
Manual
Coolant Replace coolant after flushing system.
See Engine
Manual
Coolant Filter Replace.
See Engine
Manual
Engine Oil Replace with engine manufacturer’s recommended grade and
viscosity.
See Engine
Manual
Engine Oil Filter Replace.
See Engine
Manual
Engine Thermostats Test and replace if defective.
See Engine
Manual
Fuel Filter Replace element.
See Engine
Manual
Rear Suspension Refer to the rear suspension manufacturer’s maintenance
manual for maintenance schedules, lubrication
recommendations, and inspection procedures.
See Rear
Suspension
Manual
Transmission Filters Replace with transmission manufacturer’s approved filters.
See
Transmission
Manual
Transmission Fluid Replace with transmission manufacturer’s recommended
fluids and viscosity.
See
Transmission
Manual
Wheel Bearings,
Grease (Front Axle)
Lubricate with Lithium NLGI grade EP2 grease.
See Axle
Manual
Wheel Bearings, Oil
(Front Axle)
Replace lubricant.
See Axle
Manual
Comments or Additional Items