Pierce Enforcer - Page 71

© 2020 Pierce Manufacturing Inc. All Rights Reserved. Pre-Trip Inspections / 5-5
OPERATION
5-1.5 Exterior Inspection
Perform a walk around inspection. Re-enter the cab as required during the inspection to check that exterior features
are functioning properly.
Exterior Inspection
Engine Compartment
NOTE: Secure loose items in cab and ensure the vehicle is on a flat and level surface before tilting.
Tilt the cab or open the engine compartment doors and check the following:
 Engine oil level OK.
 Automatic transmission fluid level and physical appearance OK. (Refer to “Transmission Fluid Analysis” on
page 6-27, for additional information.)
 Coolant level in radiator OK.
 Power steering fluid level OK.
 Windshield washer fluid level OK.
 Hoses show no signs of excessive wear, damage, or leaking.
 Belts are tight and show no sign of excessive wear. With engine off, press belt to test that it is snug.
 No apparent leaks of fuel, coolant, oil, power steering fluid, hydraulic fluid, or battery fluid.
 Electrical wiring insulation shows no sign of excessive wear, chafing, or damage from heat.
Batteries
 Battery box securely mounted to vehicle.
 Batteries not broken or leaking.
 Fluid in batteries at proper level (except maintenance-free type).
 Cell caps present and securely tightened (except maintenance-free type).
 Vents in cell caps free of foreign material (except maintenance-free type).
Left Front Side
 Driver’s door glass should be clean.
 Door latches and window regulators work properly.
Left Front Wheel
 Wheel and rim are in good condition – no missing, bent, or broken studs, clamps, or lugs. Show no signs of
misalignment.
 Condition of tires – properly inflated, valve stem and cap OK, no serious cuts, bulges, or excessive tread wear.
 Use wrench to test – rust streaked lug nuts, indicating looseness.
 Hub oil level OK. No leaks apparent.
Left Front Suspension
 Spring, spring hangers, shackles, U-bolts are in good condition.
 Shock absorber shows no sign of excess wear or damage.
 Torsion bar is not damaged and tape is not cut or torn. (TAK-4™ suspension only. Refer to Pierce Service
Manual, group 0152-P-007, TAK-4™ Torsion Bar Assembly.)
Left Front Brake
 Brake drums or rotors are not cracked or worn.
 Hoses show no signs of excessive wear.
PRE-TRIP AND DAILY VEHICLE INSPECTIONS
PERFORM DAILY AT THE BEGINNING OF EVERY WORK PERIOD