Piper Cherokee Six - Page 96

13.
14.
15.
Nature
of Inspection
D.
FUSELAGE
AND EMPENNAGE
GROUP
(cont)
16.
17.
18.
19.
20.
21.
22.
23.
24.
25.
26.
27.
28.
29.
30.
31.
32.
33.
34.
E.
Inspect security
of all lines ..........................................
Inspect vertical
fin and
rudder
surfaces for
damage
.....................
Inspect
rudder
hinges,
horn
and attachments
for damage
and
operation .........................................................
Inspect
rudder control
stops
to insure
stop
has not
loosened
and
locknut is
tight ....................................................
Inspect
vertical fin
attachments ......................................
Inspect
rudder
hinge bolts
for excess
wear
(Replace as
required)
.........
Inspect
stabilator
surfaces for
damage
................................
Inspect
stabilator,
tab hinges,
horn and
attachments
for
damage and
operation
.............................................
Inspect
stabilator
control
stops
to insure
stop has
not loosened
and locknut is
tight ...............................................
Inspect
security
of stabilator
attachments (see
latest Piper
Service
Bulletin
856) ......................................................
Inspect stabilator
and
tab hinge
bolts and
bearings for
excessive
wear (Replace
as required)
..................................
Inspect
stabilator
trim mechanism
installation
.........................
Inspect
aileron,
rudder,
stabilator,
stabilator
trim cables,
turnbuckles.
guides and
pulleys for
safety, damage
and
operation
......
.........
Check all
cable tensions
(use tensiometer)
(See Note 14)
................
Clean
and lubricate
stabilator trim
drum screw ........................
Clean and
lubricate all exterior
needle bearings
........................
Lubricate
per
lubrication
chart (Refer
to Section
I) ....................
Inspect rotating
beacon for
security and operation
....................
Inspect
security of Autopilot
bridle
cable clamps
(Refer to latest
revision
of Piper Service Letter No.
695) ..............................
Inspect all control
cables, air ducts, electrical
leads, lines, radio
antenna
leads and attaching parts
for security, routing, chafing,
deterioration,
wear and correct
installation
...........................
Inspect
emergency
locator transmitter
battery for
replacement
date or
time per service
manual (Refer
to latest revision
of Piper S/L
820) .......
Reinstall
inspection plates
and panels.................................
WING GROUP
PIPER CHEROKEE
SIX SERVICE MANUAL
TABLE
III-I.
INSPECTION
REPORT
(PA-32-260
and
300)
(cont)
O
Inspection Time (hrs)
50 100 500 1000
0 0 0
0 0 0
0 0 0
O O O
O O O
O O O
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
3. Inspect
security of aileron
hinges and
attachments .....................
0 0 0
0 0 0
0 0 0
Revised:
8/3/81
Interim
Revision:
5/6/87
1D24
INSPECTION