Regency P36E-NG10 - Default Chapter; Table of Contents

4 | P36E-10 Zero Clearance Direct Vent Gas Fireplace
|
4
table of contents
SAFETY LABEL
Copy of Safety Decal ..................................................... 6
REQUIREMENTS
MA Code - CO Detector.................................................6
(for the State of Massachusetts only) ............................6
Unit Dimensions with Vignette
and Vignette nishing trim .............................................7
Unit Dimensions with safety screen (#515-929)
and optional louvers ......................................................7
INSTALLATION
Important Message ...................................................... 8
Before You Start ............................................................8
General Safety Information............................................8
Installation Checklist ...................................................... 9
Locating Your Gas Fireplace .........................................9
Manufactured Mobile Home Additional Requirements ..9
Heatwave Duct System .................................................9
Heat Release kit ............................................................9
Clearances ..................................................................10
Framing .......................................................................13
Framing with vignette faceplate ................................... 14
Framing with vignette faceplate & nishing trim
nished ush................................................................14
Framing with louvers and safety screen ......................14
Finishing ......................................................................15
Wall mount On / O󰀨 Switch installation........................16
Unit Assembly Prior To Installation ..............................17
Venting Introduction ..................................................... 17
Exterior Vent Termination Locations ............................18
Venting.........................................................................19
4” x 6-5/8” Rigid Pipe Cross Reference Chart .............20
Rigid Pipe Venting Arrangements ...............................23
Vertical Termination - Co-linear Flex System ...............28
Venting Arrangements - Vertical Termination ...............29
Dura-Vent Horizontal terminations...............................30
Dura-Vent Vertical Terminations ..................................31
Direct Vent System (Flex) Installation Procedures ......32
Vertical Termination - 4'' x6-5/8'' Venting .....................33
Flex vent components .................................................34
Gas Line Installation ....................................................35
Pilot Adjustment ........................................................... 36
885 S.I.T. Valve Description .........................................36
Gas Pipe Pressure Testing ..........................................36
High Elevation .............................................................36
Conversion from NG to LP .......................................37
Optional Brick Panels ..................................................38
Log Set Installation ......................................................39
Standard Flush Door ...................................................42
Vignette faceplate and safety screen installation ........43
Vignette nishing trim installation ................................44
Optional Vignette Inlay ................................................45
Optional Finishing Trim ................................................ 46
Safety screen installation - must be used with
optional louvers ...........................................................47
Optional Flush Louvers Installation - Used with safety
screen # 515-929.........................................................47
Optional Wall Thermostat ...........................................48
AC power adaptor installation (for surere systems) ... 48
Wiring Diagram ............................................................ 49
Wiring diagram with optional fan .................................50
Optional Fan Installation .............................................. 51
Optional Wall Thermostat Installation ..........................52
OPERATING INSTRUCTIONS
Operating Instructions .................................................53
First Fire ......................................................................53
Aeration Adjustment ....................................................53
Normal Operating Sounds Of Gas Appliances ...........53
Lighting Procedure ......................................................54
Shutdown Procedure ...................................................54
Copy of Lighting Plate Instructions ..............................55
MAINTENANCE
Maintenance Instructions.............................................56
General Vent Maintenance ..........................................56
Log Replacement ........................................................56
Glass Gasket ...............................................................56
Door Glass...................................................................56
Removing Valve ...........................................................57
PARTS LIST
Main Assembly ............................................................58
Burner Assembly & Log Set.........................................59
Vignette faceplate and nishing trim ............................61
Safety screen and louvers ...........................................62
WARRANTY
Warranty ......................................................................64