Ricoh J006 - Page 240

SM 8-40 J001/J003
Problem Solution
Event Service Center Call Response
Probable Cause Operator Action
Content User
ST NR
C
Tray 1 does not
pop out of the
printer after the
raising the
output tray.
Press in gently on the paper cassette
then raise the output tray to open the
cassette.
If the cassette is closed forcefully,
the cassette pawls may mesh with
the base frame.
Press in gently on the paper cassette
then raise the output tray to open the
cassette.
Press in gently on the paper cassette then raise
the output tray to open the cassette.
X
Cover open (1) Check the Status Monitor for a
cover open message.
(2) Check the top cover for bending.
Poor contact. Check to see if the cover is open then
close it.
Check to see if the cover is open then close it. X
Interlock SW (top cover connector
disconnected).
Reconnect connector.
X
Interlock SW (rear cover
connector disconnected).
Reconnect connector.
X
Interlock SW harness
disconnected.
Replace interlock SW for top, rear covers.
X
Interlock SW (top cover)
damaged.
Replace interlock SW (top cover).
X
Repair.
Interlock SW (rear cover)
damaged.
Replace interlock SW (rear cover). X
Covers, fences
damaged
Replace/repair Unapproved operation. Replace/repair Replace/repair X
8.4.5 SPURIOUS NOISE - HORIZONTAL DRIVE SYSTEM
Problem Solution
Event
Service Center Call
Response
Probable Cause Operator Action
Content User
ST
NR
C
Rattling on right
side of printer.
Repair. Replace feed roller. Replace feed roller.
X
Squeaking from
vertical drive
Repair. Foreign object in the printer, printer needs
lubrication.
Lubricate the guide rod with oil and the rail with
grease.
X
system
Check the paper type.
X
Moaning sound
Open and close the paper
cassette.
Glossy paper can make a sound against
the bottom plate of the cassette.
Put 1 sheet of plain paper at the bottom
of the stack of glossy paper loaded in the
cassette.
Put 1 sheet of plain paper at the bottom of the
stack of glossy paper loaded in the cassette.
X
Squeaking
sound
Set several sheets of glossy
paper, not just 1 sheet.
Glossy paper may make a sound at
separation.
Remove the paper from the cassette and
reload it.
Remove the paper from
the cassette and reload it.
X
Repair. Shaft of the tension roller is squeaking. Lubricate shaft of tension roller.
X
CÓPIA NÃO CONTROLADA
CÓPIA NÃO CONTROLADA