SICK CLV63 Series Technical Information

2 Safety information
2.1 Intended use
The device consists of a bar code scanner of the product family CLV62x, CLV63x or
CLV64x in the Ethernet version with a protective housing with enclosure rating IP69K.
The protective housing comprises two parts, the bar code scanner that is permanently
installed in the protective housing at the factory and the supplied protective double
bushing including sealing materials for the two electrical connections.
The device is protected against water from high-pressure or steam cleaners and against
dust subject to use of the corresponding cables and correct mounting. For the specifi‐
cation, see "Technical data", page 27
NOTICE
The following requirements must be met in order to achieve the IP69K enclosure rating:
•
Use only the connection cables specified by SICK.
•
Seal the two cable outlets at the protective double bushing with the corresponding
O-rings.
The O-rings are included in the device scope of delivery and are matched to the outer
diameters of the plug connectors.
The device is an intelligent, opto-electronic SICK ID sensor and is used for automated,
fixed identification and decoding of bar codes on moving or stationary objects. The
device transmits the data content of the decoded bar codes to a higher-level control
(PLC) for coordinating further processing.
SICK AG assumes no liability for losses or damage arising from the use of the product,
either directly or indirectly. This applies in particular to use of the product that does not
conform to its intended purpose and is not described in this documentation.
2.2
Improper use
■
The protective housing of the factory-installed bar code scanner must not be
opened.
■
The device must not be used in explosion-hazardous areas.
■
The device does not constitute a safety-relevant device according to the EC
Machinery Directive (2006/42/EC).
■
Any other use that is not described as intended use is prohibited.
■
Any use of mounting accessories not specifically approved by SICK AG is at your
own risk.
2.3 Hazard warnings and operational safety
To reduce health risks and to avoid dangerous situations, observe the safety notes and
warnings set out in the following chapters of these operating instructions.
2.3.1 Laser radiation
The devices work with a red light laser diode in the wavelength 655 nm. They corre‐
spond to laser class 2.
2 SAFETY INFORMATION
6
T E C H N I C A L I N F O R M A T I O N | CLV62x, CLV63x and CLV64x with IP69K Protective Housing 8021479/0000/2018-03-12 | SICK
Subject to change without notice

SICK CLV63 Series Specifications

General

Brand	SICK
Model	CLV63 Series
Category	Barcode Reader
Language	English