2-STROKE PERIODIC MAINTENANCE CHART
* INITIAL INSPECTION 10-HOUR OR 500 km (300 mi)
WEEKLY OR EVERY 240 km (150 mi)
MONTHLYOREVERY800km(500mi)
EVERY YEAR OR 3200 km (2000 mi)
EVERY 2 YEARS OR 6000 km (3700 mi)
*STORAGE
A: ADJUST
C: CLEAN
I: INSPECT
L: LUBRICATE
R: REPLACE
T: PROCEED WITH TASK
*: TO BE PERFORMED BY AN
AUTHORIZED SKI-DOO DEALER
* PRESEASON
PART/TASK LEGEND
STEERING/SUSPENSION
Steering and front suspension
mechanism
(1)
A,
I,
L
A,I L
A,
I,
L
Wear and condition of skis and
runners
II
I
(1) Lubricate whenever the vehicle is
used in wet conditions
(wet snow, rain, puddles).
SUSPENSION
Suspension adjustments A AS REQUIRED
Front and rear suspensions
(1)
II,L I,L
Rear suspension stopper strap I I
(1) Lubricate whenever the vehicle is
used in wet conditions
(wet snow, rain, puddles).
ELECTRICAL SYSTEM
EMS fault codes (SDI engine only) II
Spark plugs
(3)
II R
Battery (if so equipped) I I I I
Wiring harnesses and cables I I I
Operation of lighting system
(HI/LO beam, brake light, etc.),
test operation of engine cut-out
switch and tether engine cut-out
switch
II I
(3) Before installing new spark plugs
at preseason preparation, it is
suggested to burn excess storage
oil by starting the engine with the
old spark plugs. Only perform this
operation in a well ventilated
area.
VEHICLE
Headlamp beam aiming A
Engine compartment C C C
Vehicle cleaning and protection T T T
—
_____________________
91
To Next Page
Loading...
