Stoll CMS 933 - Danger by Operating Materials; Other Dangers

1 Safety instructions
1.5 General safety instructions
1-10
1.5.3 Danger by operating materials.
Reason Protective measures
Danger of chemical burns during
contact with oil, grease and other
chemical substances.
Wear protective gear (for. e.g. safety
glasses, gloves).
Observe the country-specific laws and
regulations.
Pay attention to the Manufacturers'
instructions.
Injuries by oil pressure in case of
damaged lines of the central
lubrication that are under a high oil
pressure (30 bar).
Deactivate the machine immediately.
Secure the machine against being
switched on again.
Get the damaged lines replaced by a
mechanic.
Remove the outcoming oil immediately.
Injuries by compressed air in case of
damaged lines of the fluff absorption
that are under a high air pressure.
Deactivate the machine immediately.
Secure the machine against being
switched on again.
Get the damaged lines replaced by a
mechanic.
Danger of skidding if the oil, grease
or other substances are blocked or if
a leakage appears.
Immediately mop these substances.
Observe the country-specific laws and
regulations.
Environment pollution is caused if the
disposal of replaced parts and of
consumables is not done
professionally.
Ensure that all consumables and
replaced parts are disposed of safely
and with minimum environmental impact!
Observe the country-specific laws and
regulations.
Pay attention to the Manufacturers'
instructions.
1.5.4 Other dangers
Reason Protective measures
Increased fire and explosion hazard
by lint, dust and other impurities.
Increased danger of short circuit
during knitting of metallic or
conductive materials by building up
of metallic fluff and dust.
Lint, dust and other impurities to be
removed regularly from the entire machine
depending upon the degree of dirt atleast
once in every shift.
Take care of any additional exhaustion.
Wear Inhalation protection gear.
Danger of damage by usage of
unsuitable cleaning materials.
Only cleaning materials that have been
mentioned in the Operating Instructions
for e.g. Alcohol are to be used. Do not
use cleaning material that can cause
health hazards or is acidic/corrosive in
nature.