Terramite T6 - T6 Loader Valve Assembly

112 pages

Save Page as PDF

To Next Page

To Previous Page

A 88831 88831 Return - Front Valve Assembly Oil Cooler (SEE PAGE 3.7)

B 88880 8-8.80 Intake - Front Valve Assembly Rear Valve Assembly - Pressure Port (SEE PAGE 3.11)

T6 Loader Valve Assembly

3.10

A B

PART PREVIOUS

HOSE NUMBER PART NUMBER STARTING POINT ENDING POINT

Main Page

Table of Contents2
History of Terramite Backhoes4
Know Your Warranty4
SAMPLE Limited New Product Warranty5
Before You Start6
Safety Tips6
Before Operating the Terramite T66
Hand Signals7
Purpose and Scope7
Call Your One-Call System First8
Customer Fax Order Form9
Parts11
Operator Position for Endloader Use12
Operator Position for Backhoe Operation12
View from Left Side of Loader Bucket13
View from Front with Loader Arm Assembly Raised14
View from Front of Loader Bucket15
View from Right Side of Loader Arm Assembly16
View from Left Side of Loader Arm Assembly17
Four Wheel Drive Front Axle (Bumper Attached)19
Two Wheel Drive Front Axle (Bumper Not Shown)20
View from Left Side of 4 Point ROPS Mount21
View from Back of Seat22
View of Right Front Tire and Rim23
View of Right Rear Tire and Rim24
Front Wheel Hubs Two Wheel Drive25
Hub Assembly and Spindle Two Wheel Drive25
View from Operator Position Facing Loader26
View of Battery from the Left Side of Engine Compartment28
View of Dash Wiring Harness from Right Side of Engine Compartment29
View of Air Cleaner and Radiator from Operator Position30
View of under Side of Air Cleaner31
View from Right Side of Engine Compartment32
View from Left Side of Engine Compartment33
Exploded View of Energy Isolating Engine Mount34
View from Top of Transmission Assembly35
Top View of Parking Brake Assembly36
Drive Shaft Coupler for the 2 WD37
Drive Shaft Coupler/13 Tooth Spline for the 4 WD37
View from Front of Rear Axle - Parking Brake Assembly38
View from Left Side of Rear Axle - Drum Brake39
View from Left Side of Fuel Tank40
View from Right Side of Hydraulic Tank41
View of Deck Lid in Front of Operator Seat42
View of Deck Lid (Behind Operator Seat)42
View from Right of Foot Pedal Control - 2WD43
Close up of Pedal Spring Installation43
View of Cam Roller Center Spring45
Exploded View of Rear Transmission 4WD Brackets46
View from Operator Position of Backhoe Valve48
View of Flip over Pads53
View of Loader Valve Assembly54
View of Front Valve Linkage Assembly55
View from Right Side of Swing Assembly56
View from Right Side Top of Swing Assembly57
View from Right Side of Boom58
View of Right Side of Rear Bucket & Linkage Assembly59
View of Left Side of Rear Bucket & Linkage Assembly60
Quick Attach Backhoe Buckets61
Tooth Caps62
Hydraulic System Oil Change and Type Specifications63
On Hand Spare Parts63
Special Tools63
Purging Air from Fuel System Service Procedures64
T6 Transmission - 2WD67
T6 Torque Motor - 2WD68
T6 Transmission - 4WD69
T6 4WD Front Axle Assembly70
T6 Torque Motor - 4WD71
T6 4WD Cartridge Block72
T6 Oil Cooler73
T6 Steering Column 2WD and 4WD74
T6 Power Steering Cylinder75
T6 Loader Valve Assembly76
T6 Backhoe Valve Assembly77
T6 Filter Assembly78
T6 Drive System Distributor Block79
T6 Hydraulic Oil Tank Assembly80
T6 Backhoe Hydraulic Circuit Wobblestick Hose Digram 2WD & 4WD81
T6 Backhoe Hydraulic Circuit Wobblestick Hose Diagram 4WD82
T6 Loader Hydraulic Circuit Hose Lengths (In.)83
Components84
T6 Wiring Diagram - Perkins 103-1585
MAB/MAE Torquemotor Exploded Assembly View - Typical86
Rear Axle Assembly87
General Tightening Torque for Bolts, Nuts and Taperlock Studs89
Metric Fasteners89
Metric ISO Thread89
Schematic-View of Typical Control Valve Assembly90
Parts Ordering Information91
Seal Kit Changes91
4-Way, 3-Position Valve Section92
Load Check Plug Assembly93
SPK Monoblock Valve94
Model J-HP High Pressure Relief95
Options96
Clam Shell 4 in 1 Bucket97
View of Clam Shell 4 in 1 Bucket from Drivers Position98
View under the Dash for Clam Shell 4 in 1 Bucket99
Translations100
Translation Chart101
Index107
Index108

Terramite T6 - T6 Loader Valve Assembly

Table of Contents