Thomas T105 User Manual

29
4...MAINTENANCE
ITEM SERVICE REQUIRED
8 HOURS
50 HOURS
150 HOURS 400 HOURS
1000 HOURS
Engine Oil
Radiator
Hydraulic Oil
Air Cleaner
Tires and Wheel Nuts
Safety Equipment
Decals
Hydraulic Oil Filter
50 Hour Service
Lubrication
Engine Oil
Engine Oil Filter
Muffler
Safety System Linkages
and Springs
Hydraulic Oil Filter
50 Hour Service
Final Drive
Engine Oil
Engine Oil Filter
Hydraulic Oil Filter
Check level and add if necessary. Use appropriate oil (See Section 5
for appropriate oil).
Check level and add if necessary. Fill with 50% mixture of ethylene
glycol and water. Check cooling fins for dirt. If necessary blow out
with compressed air. Check rubber seal around radiator baffle.
Check level and add if necessary. Use appropriate oil (See Section 5
for appropriate oil).
Empty dust cap. Check condition indicator and service or replace
element as required.
Check for low pressure or tire damage.Inflate standard tires 30 - 35
PSI (345 KPa), flotation tires 30 - 35 PSI (207 - 241 KPa). Check
wheel nut torque 100 - 110 ft. lbs. (136-149 N m)
Check all safety equipment for proper operation and condition. Seat
belt, lift arm supports, quick - tach locks, parking brake, foot pedal
locks, safety treads . Repair or replace if necessary.
Check for damaged safety or instruction decals (see section 5.4). If
necessary replace.
Check Filter Service Indicator
Perform complete 50 hour service (see 4. 3).
Grease all hinge pin fittings until excess shows.
Replace engine oil. (See Section 5 for appropriate oil). Initial
change only.
Change engine oil filter element. Initial change only.
Check the muffler for carbon buildup and plugging. If necessary
clean. Check every 100 hours.
Check and if necessary adjust. Lubricate foot pedal lock springs,
shaft and linkage with a silicone based lubricant.
Change hydraulic oil filter element. Initial change only.
Perform complete 50 hour service (see 4. 3).
Check chain and sprocket condition. Check every 150 hours.
Replace engine oil (initial change already made) (See Section 5 for
appropriate oil). Replace every 200 hours.
Replace engine oil filter. See 4. 7 - 3. Replace every 200 hours
Replace engine oil filter every 150 hrs or when the Service Indicator
shows red.
4.1 PREVENTIVE MAINTENANCE SERVICE SCHEDULE
200 HOURS

Thomas T105 Specifications

General

Brand	Thomas
Model	T105
Category	Compact Loader
Language	English