Toro Reelmaster 5210 - Chapter 5 - Electrical System; Adjustments; General Information; Chapter 6 - Chassis

Reelmaster 5010 Series Page 3 -- 1 Kubota Diesel Engine
Chapter 3
Kubota Diesel Engine
Table of Contents
GENERAL INFORMATION 1.....................
T raction Unit Operator’s Manual 1...............
Stopping the Engine (Reelmaster 5610) 1........
SPECIFICATIONS 2............................
Reelmaster 5210 2............................
Reelmaster 5410 and 5510 3...................
Reelmaster 5610 4............................
ADJUSTMENTS 5..............................
Adjust Throttle Control 5.......................
SERVICE AND REPAIRS 6......................
Fuel System 6................................
Air Cleaner 8.................................
Exhaust System 10...........................
Radiator 12..................................
Engine 14....................................
KUBOTA WORKSHOP MANUAL: 05 SERIES DIESEL
ENGINE
General Information
This Chapter gives information about specifications,
troubleshooting, testing and repair of the Kubota diesel
engine used in the Reelmaster 5010 Series of ma-
chines.
Most repairs and adjustments require tools which are
commonly available in many service shops. The use of
some specialized test equipment is explained in the en-
gine service manual included at the end of this chapter.
However , the cost of the test equipment and the special-
ized nature of some repairs may dictate that the work be
done at an engine repair facility.
Service and repair parts for Kubota diesel engines are
supplied through your local Toro Distributor. If a parts list
is not available, be sure to provide your distributor with
the Toro model and serial number.
Traction Unit Operator’s Manual
The T raction Unit Operator’s Manual provides informa-
tion regarding the operation, general maintenance and
maintenance intervals for the Kubota diesel engine that
powers your Reelmaster machine. Refer to that publica-
tion for additional information when servicing the ma-
chine.
Stopping the Engine (Reelmaster 5610)
IMPORTANT: The engine used on the Reelmaster
5610 is turbo--charged. Before stopping the engine
after mowing or full load operation on Reelmaster
5610 machines, cool the turbo-charger by allowing
the engine to idle at low speed for 5 minutes. Failure
to do so may lead to turbo-charger trouble.
Kubota Diesel
Engine