Tuttnauer 6671130 - Electrical Control System Drawing

MAN205-0195042EN Rev. A Aug. 2011
Page 35 of 137 pages
ELECTRICAL CONTROL SYSTEM DRAWING
TUTTNAUER
ISO
A4
Description:
Design:
REV. No.
Drawing:
Job No.
Scale:
Drawing No.
Quant./Unit: Quant./Job:
Approved by:
Cat. No.
Q. C.
00
Drawing for horizontal autoclave with two sliding doors
Page 1 From 1
Yan S.
Marchel. N
Yan. S
17.07.2011
17.07.2011
17.07.2011
PKZM 0-6.3
Vacuum Pump
DILM12
R
S
T
GND
Power Supply
RS25-5
Power Supply
RPD-65D
CB1 4A
EMERGENCY STOP
CAT2007
DIGITAL OUTPUTS
12345678
Out 1
Out 2
Out 3
Out 4
Out 5
Out 6
Out 7
Out 8
Out 9
Out 10
Out 11
Out 12
Out 13
Out 14
Out 15
Out 16
Out 17
Out 18
Out 19
Out 20
Out 21
Out 22
Out 23
Out 24
POWER OUT 24VDC
24V
5V
GND
INPUT 1
INPUT 2
INPUT 3
INPUT 4
INPUT 5
INPUT 6
INPUT 7
INPUT 8
INPUT 9
INPUT 10
INPUT 11
INPUT 12
INPUT 13
INPUT 14
INPUT 15
INPUT 16
DIGITAL INPUTS
GND
GND
GND
5V
5V
24V
24V
4-20mA Sensors
6
5
4
3
2
1
7
PT100 Sensors
3
2
1
4
5
6
ANL OUT
ANL IN
COMPUTER
Limit door1 sw.
Float vac.pump sw.
Safety door1 switch
SSR
1
2
3 4
Press Chamber
Press Jacket
Press Door1 Seal
PT100-1CONDENSE
PT100-5COOLING DRAIN
PT100-2 CONDENSE
3x208V/60Hz
Safety
Interlock
RT112
154393
91
74
12
38-1
39-194-1
53-1
75
Water to Vacuum Pump
Filtered Air Inlet
Steam Inlet to Chamber
Steam Inlet to Jacket
Slow Exhaust to Drain
Feed Water to Cooling Drain
Close door 1
Open door 1
Vacuum from gasket door 1
Steam to gasket door 1
N
ALCO
Exhaust to Vacuum Pump
H02SF01
ELSALVADOR11001809
OPTION
PANEL1 PANEL2
To Panel 2
PS 5VDC
Press Door2 Seal
Safety door2 switch
Limit door2 sw.
38-2
ALCO
39-294-2
53-2
Open door 2
Close door 2
Steam to gasket door 2
Vacuum from gasket door 2
1 2
90
92
Steam from Building
Steam from Generator
On/Off Switch
P1-25