Aichi SP14DJ - Diagnostic Codes Chart

71
2. LoadingtheMachine
DANGER
•Toavoidslip-offandrun-off,remove
mudoroilfromtiresandramp.Inrainy
condition,donotperformaloadingwork
toavoidslipofftheramp.
•Failuretoavoidthesefallhazardscould
resultindeathorseriousinjury.
WARNING
•Donottravelthemachineonaslopethat
exceedsthemachinegradeability.
 Useawinchforloading/unloading,ifthe
rampistoosteeporslippery.
•Ifthetransportvehicleandtheloading
rampareinclinedtotheleftorright
excessively,thewheelsofthemachine
mayfallofftheramp.
•Donotturnthesteeringofthemachine
whileitisontheramp,becauseofthe
possibilityofafall.
•Whenloading/unloading,besuretohavea
guideassistyousothatthewheelsdonot
fallofftherampandthetransportvehicle
bed.
•Travelwiththecounterweightuphillwhile
themachineisonaslope.
•Failuretoavoidthesefallhazardscould
resultindeathorseriousinjury.
󱒸󱓙󱓊󱓕󱒅󱒖
 Parkthetransportvehicleonlevelfirmsurface.
󱒸󱓙󱓊󱓕󱒅󱒗
 Chockthewheelsofthetransportvehicle.(Fig.
10‒2,A)
C A
BB
M098K4-1
Fig.10‒2
󱒸󱓙󱓊󱓕󱒅󱒘
 Attachtheloadingrampatassmallanangleas
possible.(Fig.10‒2,C)
󱒸󱓙󱓊󱓕󱒅󱒙
 Setthetravelspeedselectswitchto“ ”(LOW
SPEED)or“
”(HIGHTORQUE).
󱒸󱓙󱓊󱓕󱒅󱒚
 Travelwiththecounterweightuphill,asshown
inFig.10‒2.
 Drivethemachinestraightforwardor
backwardatlowspeedontotheramp,and
loadthemachineontothetransportvehicle.
NOTICE
•Themachineisequippedwithasystem
thatautomaticallychangesatravelmode:
travelspeedandtorque,toassisttraveling
onaslope.Thesystemmightmomentarily
stoporbackthemachinejustafterhaving
goneupontoaslope.
•Ifthereisaleveldifferencebetweenthe
loadingrampandthefloorsurface,the
machinemaynotbeabletotraveluponto
theramp.Inthiscase,minimizethelevel
differenceusingthresholdramporstrips.
󱒸󱓙󱓊󱓕󱒅󱒛
 Shutoffthemachineandchockthewheelsof
themachine.(Fig.10‒2,B)
󱒸󱓙󱓊󱓕󱒅󱒜
 Turnthekeyswitchto“ ”(OFF)toshutdown
theengine,removethekeytopreventusing
themachinewithoutpermission,andstoreit
suitably.
󱒸󱓙󱓊󱓕󱒅󱒝
 Firmlycloseallthedoorsofthemachine.Make
suretolockalldoorsthatareequippedwitha
door-lock.
WARNING
 Doorsopeningsuddenlythroughthe
movementsofthemachinecouldhit
otherloadings,resultinginfallinghazard.
󱒨󱓍󱓆󱓕󱓙󱓊󱓗󱒅󱒖󱒕󱒅󱒒󱒅󱒹󱓗󱓆󱓓󱓘󱓕󱓔󱓗󱓙󱓎󱓓󱓌