KBF / KBF P (E5.2) 02/2012 page 22/103
Note on second-hand units (Ex-Demo-Units):
Second-hand units are units that were used for a short time for tests or exhibitions. They are thoroughly
tested before resale. BINDER ensures that the chamber is technically sound and will work flawlessly.
Second-hand units are marked with a sticker on the unit door. Please remove the sticker before commis-
sioning the unit.
3.2 Guidelines for safe lifting and transportation
The front castors of KBF / KBF P 240 and 720 can be blocked by brakes. Please move the units with cas-
tors only when empty and on an even surface, otherwise the castors may be damaged. After operation,
please observe the guidelines for temporarily decommissioning the unit (chap. 17.2).
CAUTION
Sliding or tilting of the unit.
Damage to the unit.
Risk of injury by lifting heavy loads.
Transport the unit only in its original packaging.
For moving or shipping, secure the climatic chamber with transport straps.
∅ Do NOT lift or transport the unit using the door, the handle, or the lower housing.
Lift units size 115 at the four lower corners with the aid of 4 people
Lift units size 240 corners with the aid of 6 people or with a fork lifter. Set the fork lifter
only from the front or rear in the middle of the unit.
Lift units size 720 using technical devices (fork lifter). Set the fork lifter only from the
front or rear in the middle of the unit.
∅ Do NOT set the fork lifter from the unit side.
You can order transport packing for moving or shipping purposes from BINDER service.
Permissible ambient temperature range during transport:
• If the steam humidifying system has NOT been emptied: +3 °C / 37.4 °F to +60 °C / 140 °F.
• After BINDER Service has emptied the steam humidifying system: -10 °C / 14 °F to +60 °C / 140 °F.
With temperatures below +3 °C / 37.4 °F, water must be completely removed from the humidifying sys-
tem.
CAUTION
Transport below +3 °C / 37.4 °F with filled steam humidifying system.
Freezing in the steam generator.
Damage to the unit.
Contact BINDER Service before any transportation below +3 °C / 37.4 °F.
To Next Page
Loading...
