Chicago Dryer EDGE - Page 7

Edge/Edge Blanket Table of Contents
v
7.4 Transfer Section ...................................................................................... 7-9
Transfer Clamp Check and Adjustment ................................................... 7-9
Transfer Clamp Assembly Replacement ................................................7-11
Transfer Clamp Roller Adjustment ........................................................ 7-13
Rodless Air Cylinder Carrier Bracket Tension Adjustment ..................... 7-14
7.5 Spreader Section ..................................................................................
7-14
Spreader Clamp Mechanical Adjustment .............................................. 7-15
Upper Spreader Belt Tension Adjustment ............................................. 7-15
Upper Spreader Belt Replacement ....................................................... 7-16
Upper Spreader Clamp Linear Bearing Replacement ........................... 7-17
Lower Spreader Drive Belt Tension Adjustment .................................... 7-18
Lower Spreader Drive Belt Replacement .............................................. 7-19
Lower Spreader Belt Replacement ....................................................... 7-19
Lower Spreader Belt Gap Adjustment ................................................... 7-20
7.6 Discharge Section .................................................................................
7-23
Discharge Conveyor Ribbons Tension Adjustment ............................... 7-23
Discharge Conveyor Ribbons Replacement ......................................... 7-24
Discharge Conveyor Guide Ribbons Tension Adjustment/Replacement ......
7-26
Discharge Conveyor Drive Belt Tension Adjustment ............................. 7-27
Discharge Conveyor Drive Roll Tracking Tape Replacement ................ 7-27
Discharge Conveyor Doffer Roll Pressure Adjustment .......................... 7-28
Discharge Conveyor Doffer Roll Cover Replacement ........................... 7-29
7.7 Sensors .................................................................................................
7-31
General Photosensor Alignment ........................................................... 7-31
Corner Photosensors Alignment ........................................................... 7-32
Roll Photosensors Alignment ................................................................ 7-33
Taut Photosensors Alignment ................................................................ 7-34
Tail Photosensor Alignment ................................................................... 7-35
General Photosensor Sensitivity Adjustment ........................................ 7-36
Roll Photosensors Sensitivity Adjustment ............................................. 7-37
Photosensor Replacement .................................................................... 7-38
Proximity Sensor Positioning Adjustment .............................................. 7-39
Proximity Sensor Replacement ............................................................. 7-40