14.7.16 Inhalt/Contens Seite/Page 5
Inhalt / Contens
7.7.2 Installation area of the waterlock .................................................................................... .... 57
7.7.3 The volume of the waterlock ........................................................................................... .... 58
7.7.3.1 Ideal position of the waterlock.......................................................................... .... 58
7.7.3.2 Example of the installation of the waterlock off-center and possible effects:... .... 60
7.8 Exhaust / water separator............................................................................................................... .... 61
7.9 Installation exhaust water separator............................................................................................... .... 62
7.10 Fuel system installation .................................................................................................................. .... 63
7.10.0.1 The following items need to be installed: ......................................................... .... 63
7.10.1 Connection of the fuel lines at the tank .......................................................................... .... 64
7.10.2 Position of the pre-filter with water separator ................................................................. .... 65
7.11 Ventilating the fuel system.............................................................................................................. .... 65
7.12 Generator DC system installation................................................................................................... .... 66
7.12.1 Connection of the starter battery block ........................................................................... .... 66
7.12.2 Connection of the remote control panel - See Panda iControl panel manual ................. .... 69
7.12.3 Fuse ............................................................................................................................... .... 69
7.12.4 Installation of the iControl panel - See iControl Manual ................................................. .... 70
7.13 Generator AC System Installation .................................................................................................. .... 70
7.13.1 Installation PMGi inverter - See separate PMGi 5000 inverter manual .......................... .... 71
7.13.2 Power source selector .................................................................................................... .... 71
7.14 Checking and filling of the oil circuit................................................................................................ .... 73
7.15 Isolation test.................................................................................................................................... .... 73
7.16 Initial operation ............................................................................................................................... .... 73
8 Maintenance Instructions....................................................................................................................... ..... 75
8.1 Personal requirements.................................................................................................................... .... 75
8.2 Personal requirements.................................................................................................................... .... 75
8.3 Hazard notes for the maintenance and failure................................................................................ .... 75
8.4 Environmental protection................................................................................................................ .... 77
8.5 General maintenance instructions .................................................................................................. .... 77
8.5.1 Checks before each start ................................................................................................ .... 77
8.6 Maintenance interval....................................................................................................................... .... 77
8.6.1 Check of Hoses and Rubber Parts in the sound insulated capsule ................................ .... 77
8.7 Oil Change Intervals ....................................................................................................................... .... 78
8.8 Checking oil-level............................................................................................................................ .... 78
8.8.1 Refilling Oil ..................................................................................................................... .... 79
8.8.2 After the oil level check and refilling the oil ..................................................................... .... 79
8.9 Replacement of engine oil and engine oil filter............................................................................... .... 80
8.9.1 After the oil change ........................................................................................................ .... 82
8.10 Verifying the starter battery and (if necessary) the battery bank .................................................... .... 82
8.11.1 Exchange of the Fuel Filter ............................................................................................. .... 83
8.11.2 De-aerating the fuel system ............................................................................................ .... 83
8.11.3 Replacement of the air filter ............................................................................................ .... 84
8.12 De-aerating of the coolant circuit / freshwater ................................................................................ .... 85
8.13 The raw water circuit....................................................................................................................... .... 85
8.13.1 Clean raw water filter ...................................................................................................... .... 85
8.13.2 Causes with frequent impeller waste .............................................................................. .... 85
To Next Page
Loading...
