10 SERVICE SCHEDULE
28
10.1 Additional information
Any further work that results from the service work must be ordered separately and invoiced separately.
Different service intervals may apply in your country, depending on the local operating conditions.
Individual service intervals and scopes may change in the course of technical developments. The most up-to-date
service schedule can always be found on KTM Dealer.net. Your authorized KTM dealer will be happy to advise
you.
Always bring the battery charger with you when having the vehicle serviced.
The use of a service hour counter is recommended in order to be able to check the mileage at any time.
Service hour counter (45412920000)
10.2 Service schedule
every 12 months
Every 80 operating hours
Every 40 operating hours
Every 20 operating hours
After 10 operating hours
Check the battery charger plug for damage and dirt. ○ ● ● ●
Read out the fault memory using the KTM diagnostics tool. ○ ● ● ●
Check that the electrical system is functioning properly. ○ ● ● ●
Check and charge the LV traction battery. ○ ● ● ●
Check that the brake linings of the front brake are secured. ( p. 69) ○ ● ● ●
Check that the brake linings of the rear brake are secured. ( p. 77) ○ ● ● ●
Check the brake discs. ( p. 66) ○ ● ● ●
Check the brake lines for damage and leakage. ○ ● ● ●
Check the front brake fluid level. ( p. 67) ○ ● ● ●
Change the front brake fluid. ●
Check the rear brake fluid level. ( p. 74) ○ ● ● ●
Change the rear brake fluid. ●
Change the sealing cup of the rear brake cylinder. (SX‑E 5) ● ● ●
Check the play of the front brake lever. ( p. 66) ○ ● ● ●
Check the free travel of the rear brake lever. ( p. 72) ○ ● ● ●
Check cables and wires for damage and kink-free installation. ○ ● ● ●
Check the frame. ( p. 64) ● ● ●
Check the link fork. ( p. 64) ● ● ●
Check the fork bearing for play. ● ● ●
Check the heim joint for play. ● ● ●
Check the tire condition. ( p. 85) ○ ● ● ●
Check tire pressure. ( p. 86) ○ ● ● ●
Check the wheel bearing for play. ● ● ●
Check the wheel hubs. ● ● ●
Check the rim run-out. ○ ● ● ●
Check the spoke tension. ( p. 86) ○ ● ● ●
Check the chain, rear sprocket, motor sprocket, and chain guide. ( p. 61) ○ ● ● ●
Check the chain tension. ( p. 60) ○ ● ● ●
Grease all moving parts (e.g., hand lever, chain, ...) and check for smooth operation. ○ ● ● ●
Service the fork. ● ●
To Next Page
Loading...
