Home
MTU
Engine
12V2000Gx6 series
MTU 12V2000Gx6 series User Manual
5
of 1
of 1 rating
239 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
8.21.1
Engine cabling – Check
221
8.22
Accessories for (Electronic) Engine
Governor / Control System
222
8.22.1
Engine governor and connector – Cleaning
222
9
Appendix A
9.1
List of abbreviations
223
9.2
MTU Contact/Service Partners
225
10
Appendix B
10.1
Special Tools
226
10.2
Index
236
MS15054/03E 2018-07
|
Table of Contents
|
5
DCL-ID: 0000037216 - 007
4
6
Table of Contents
Default Chapter
1
Operating Instructions
1
Table of Contents
3
1 Safety
6
Important Provisions for All Products
6
Correct Use of All Products
8
Personnel and Organizational Requirements
9
Initial Start-Up and Operation - Safety Regulations
10
Assembly, Maintenance, and Repair Work - Safety Regulations
12
Fire and Environmental Protection, Fluids and Lubricants
16
Compressed Air
17
Standards for Warning Notices in the Text and Highlighted Information
18
2 Transport
19
3 General Information
20
Engine Side and Cylinder Designations
20
Engine Overview
21
Sensors and Actuators - Overview
22
4 Technical Data
26
Product Data 12V/16V2000Gx6S, 3B, Continuous Operation, Variable Load, ICXN, Optimized Fuel Consumption
26
Product Data 12V/16V2000Gx6S, 3D, Standby Power, Fuel Stop Power, IFN, Optimized Fuel Consumption
30
Product Data 12V/16V2000Gx6S, 3F, Mains Backup Mode, Unlimited, ICXN, Optimized Fuel Consumption
34
Product Data 12V/16V2000Gx6S, 3G, Continuous Operation, Time-Limited, ICXN, Optimized Fuel Consumption
37
Product Data 12V/16V2000Gx6S, 3H, Mains Backup Mode, Special Qualification, Optimized Fuel Consumption
40
Product Data 12V/16V2000Gx6S, 3B, Continuous Operation, Variable Load, ICXN, EPA Nonroad T2 (40CFR89)
44
Product Data 12V/16V2000Gx6S, 3D, Standby Power, Fuel Stop Power, IFN, EPA Nonroad T2 (40CFR89)
48
Product Data 12V/16V2000Gx6S, 3F, Mains Backup Mode, Unlimited, ICXN, EPA Nonroad T2 (40CFR89) and EPA Stationary EMERG T2 (40CFR60)
52
Product Data 12V/16V2000Gx6S, 3G, Continuous Operation, Time-Limited, ICXN, EPA Nonroad T2 (40CFR89)
56
Product Data 12V/16V2000Gx6S, 3H, Mains Backup Mode, Special Qualification, EPA Nonroad T2 (40CFR89) and EPA Stationary EMERG T2 (40CFR60)
59
Firing Order
63
Engine - Main Dimensions
64
5 Operation
65
Putting the Engine into Operation after Extended Out-Of-Service Periods (>3 Months)
65
Putting the Engine into Operation after Scheduled Out-Of-Service-Period
66
Engine - Starting
67
Re-Starting the Engine Following an Automatic Safety Shutdown
68
Operational Checks
69
Emission Label - Check
70
Engine Shutdown
71
Stopping the Engine
71
Emergency Engine Shutdown
72
After Stopping the Engine
73
Plant - Cleaning
74
6 Maintenance
75
Maintenance Task Reference Table [QL1] for Non-EPA Regions
75
Maintenance Task Reference Table [QL1] for EPA Regions
76
7 Troubleshooting
77
Troubleshooting 7.1 Troubleshooting
77
Engine Control Unit - ECU9 Fault Messages
80
Engine
108
Engine - Test Run
108
Engine - Barring Manually
109
Engine - Barring with Starting System
110
8 Task Description
108
Cylinder Liner
111
Cylinder Liner - Instructions and Comments on Endoscopic and Visual Examination
111
Cylinder Liner - Endoscopic Examination
113
Crankcase Breather
115
Crankcase Breather - Oil Mist Separator Replacement
115
Fan Drive
116
Drive Belt - Condition Check
116
Drive Belt - Tension Check
117
Drive Belt - Tension Adjustment
119
Drive Belt - Replacement
120
Valve Drive
121
Valve Clearance - Check and Adjustment
121
Adjusting Valve Clearance
122
Cylinder Head Cover - Cylinder Head Cover
124
Injector
126
Injector - Replacement
126
Injector - Removal and Installation
127
Injector Functions
132
Fuel System
133
HP Fuel Line and Pressure Pipe Neck - Replacement
133
Fuel System - Venting
136
Fuel - Draining
137
Fuel Cooler - External Contamination and Leak-Tightness Check
138
Fuel Cooler - Cleaning
139
Fuel Filter
141
Fuel Filter - Replacement
141
Fuel Prefilter - Draining
142
Fuel Prefilter (Non-Switchable) - Draining
143
Fuel Prefilter (Switchable) - Draining
145
Fuel Prefilter - Pressure Ratios
148
Fuel Prefilter (Switchable) - Low Pressure Indicator Check
149
Fuel Prefilter (Non-Switchable) - Filter Element Replacement
150
Fuel Prefilter (Switchable) - Filter Element Replacement
152
Fuel Prefilter - Venting
155
Air Filter
157
Air Filter - Replacement
157
Air Filter - Removal and Installation
158
Air Intake
159
Service Indicator - Signal Ring Position Check
159
Starting Equipment
160
Electric Starter - Overview
160
Starter - Removal
161
Starter - Installation
162
Pneumatic Starter - Overview
163
Starter - Removal
164
Starter - Installation
165
Lube Oil System, Lube Oil Circuit
166
Engine Oil Level - Check
166
Engine Oil - Change
167
Oil Filtration / Cooling
168
Engine Oil Filter - Replacement
168
Coolant Circuit, General, High-Temperature Circuit
169
Engine Coolant - Level Check
169
Engine Coolant Change
170
Engine Coolant - Draining
171
Engine Coolant - Filling
172
Engine Coolant Pump - Relief Bore Check
174
Engine Coolant - Sample Extraction and Analysis
175
Low-Temperature Circuit
176
Charge-Air Coolant - Filling
176
Charge-Air Coolant - Draining
178
Charge-Air Coolant - Change
179
Charge-Air Coolant Level - Check
180
Charge-Air Coolant Pump - Relief Bore Check
181
Intercooler - Checking Condensate Drain for Coolant Discharge and Obstructions
182
Battery-Charging Generator
183
Drive Belt - Condition Check
183
Drive Belt - Tension Check
184
Drive Belt - Tension Adjustment
186
Drive Belt - Replacement
187
Preheater
188
Preheater - Overhaul
188
Preheater - Function and Leak Check
189
Preheater - Heating Element and Housing Check
190
Preheater - Heating Element and Housing Check
193
Preheater - Heating Element and Housing Check
196
Preheater - Solenoid Switch Replacement
199
Preheater - Solenoid Switch Replacement
201
Preheater - Solenoid Switch Replacement
203
Preheater Thermostats - Replacement
205
Preheater Thermostats - Replacement
208
Preheater Thermostats - Replacement
211
Engine Mounting / Support
214
Engine Mounting - Checking Securing Screws for Firm Seating
214
Engine Mounting - Checking Condition of Resilient Mounts
215
Generator
216
Generator Mounting - Checking Condition of Resilient Mounts
216
Generator Mounting - Checking Firm Seating of Securing Screws
217
Engine Governor
218
Engine Control Unit - Overview
218
Engine Control Unit - Removal and Installation
219
Engine Governor Plug Connections - Check
220
Engine Cabling – Check
221
Wiring (General) for Engine/Gearbox/Unit
221
Accessories for (Electronic) Engine Governor / Control System
222
9 Appendix A
223
9 Appendix A List of Abbreviations
223
MTU Contact/Service Partners
225
10 Appendix B
226
Special Tools
226
Index
236
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the MTU 12V2000Gx6 series and is the answer not in the manual?
Ask a question
MTU 12V2000Gx6 series Specifications
General
Brand
MTU
Model
12V2000Gx6 series
Category
Engine
Language
English
Related product manuals
MTU 12V2000M93
163 pages
MTU 12V2000M91
169 pages
MTU 12V2000M72
185 pages
MTU 12V2000M86106
170 pages
MTU 12V4000T94
189 pages
MTU 12V4000G34F
262 pages
MTU 12V4000L32FB
183 pages
MTU 12V 2000 G63
214 pages
MTU 12V4000M93 series
267 pages
MTU 12V4000M*3 series
375 pages
MTU Detroit Diesel 12V 183 TB.2
596 pages
MTU Detroit Diesel 12V 183 TD.2
596 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General