RX1575 SERIES TRENCH ROLLER • OPERATION MANUAL S/N 3069933~ — REV. #0 (11/29/23) — PAGE 13
MAJOR SAFETY PRECAUTIONS
22 RAMMAX 1575
2.1 Major Safety Precautions
• To use the machine in a case of an obvious defect.
• To use the machine when the level of any operating uid
is low.
• To repair the engine without authorization – except com-
mon changes of operating uids and lters, only an au-
thorized service organization is allowed to intervene in the
engine, including the peripheral components of the engine
(for example, the alternator, the starter, the thermostat, the
electrical installation of the engine.
• Operate the machine in potentially explosive atmospheres
(ATEX) and underground areas.
• To use the machine under the inuence of alcohol or drugs.
• To use the machine if its operation might pose risk to its
technical condition, to safety (life, health) of persons, to fa-
cilities or objects or to road trac and its uency.
• To put the machine into operation and use it when other
persons are within its hazardous reach – the exception is
training of a driver by an instructor.
• Operate or use the machine if any safety device is removed
or damaged.
• Operate the machine from outside the safe zone. The sense
of the controls does not correspond to the movement of the
machine.
• To drive the machine and use it for compacting at such
slopes where the machine stability would be breached
(overturning). The stated machine static stability is reduced
by dynamic eects of driving.
• To drive the machine and use it for compacting at such
slope angles where there is hazard of soil breaking o under
the machine or a risk of a loss of adhesion and uncontrolled
skidding.
• To control the machine in any other way than stated in op-
eration manual.
• Drive and compact with vibration according to the load-
bearing capacity of the soil at a distance from the edge of a
slope or trenches in which there would be a risk of landslide
or shoulder breaking o (dropping) with the machine.
• Drive and compact with vibration in such a distance from
walls, cuts and slopes where there is a risk of landslide and
the machine could be covered up with soil.
• Drive with vibration on a hard (frozen, concrete, overcom-
pacted) surface or on a bedrock. There is a risk of damaging
the machine.
• To compact with vibration in such a distance from buildings,
facilities or equipment, within which risk of their damage
due to vibration could occur due to the transmission of vi-
brations.
• To move and transport persons on the machine.
• To operate the machine with the bonnet lifted o.
• To operate the machine if there are other machines or
means of transport within its hazardous reach, except those
that operate in mutual cooperation with the machine.
• To operate the machine at a place that is not seen from the
driver’s stand and where hazard to people or property could
occur unless work safety is ensured by another way, e.g. with
mediate signalling by a duly instructed person.
• To operate the machine in a protected zone of electric lines
or substations.
• Do not cross electric cables if they are not properly protect-
ed against mechanical damage.
• Work with the machine above the level of the machine op-
erator.
• To operate the machine at reduced visibility or at night, un-
less the machine’s working area and the workplace are suf-
ciently illuminated.
• Sitting on external parts of the machine while driving.
• To leave the machine unattended – to move away from the
machine without having prevented its misuse.
• To disable safety, protective or locking systems or alter their
parameters.
• To use the machine with leaking oil, fuel, cooling liquid or
other llings.
• To start the engine in a dierent way than specied in the
operation manual.
• To lay materials or other objects on the machine.
• To remove dirt while the machine is running.
• To perform maintenance, cleaning or repairs when the ma-
chine is not secured against spontaneous move or acciden-
tal start and when contact of a person with moving parts of
the machine is not excluded.
• To touch moving parts of the machine with the human body
or objects and tools held in hands.
• To smoke or handle a naked ame when checking or pump-
ing fuels, exchanging or relling oils, lubricating the ma-
chine and inspecting or relling the accumulator.
• To carry rags saturated from inammable materials and in-
ammable liquids in unbound/loose vessels on the machine
(in the engine space).
• Leave the engine running in enclosed, unventilated areas.
Exhaust fumes are dangerous to life.
• To perform any adjustments on the machine without the
prior consent of the manufacturer.
• To move electrical conductors.
• To use other than original spare parts.
• To intervene in the electrical and electronic units in any
manner.
• To ll the hydraulic circuit during the guarantee period in a
dierent way than using the hydraulic unit.
Breaching these provisions can inuence the evaluation
of a possible complaint and eect of the machine guar-
antee period.
2.1.4 Forbidden activities – safety andguarantee
It is prohibited:
To Next Page
Loading...
