NLB 1012D - Table of Contents

Revision 11
TABLE OF CONTENTS
SECTION
4
OPERATION CONTROL
DESCRIPTION PAGE NUMBER
Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
I. Machine Control ................................................ 4-2
A. Control Devices ............................................. 4-2
1. Push Buttons ............................................. 4-2
2. Pilot Lights .............................................. 4-2
3. Push Button Pilot Lights .................................... 4-2
4. Selector Switch ........................................... 4-2
5. Float Switch ............................................. 4-2
B. Control Panel - CUMMINS Diesel Engine . . . . . . . . . . . . . . . . . . . . . . . . 4-3
1. Control Panel Layout - CUMMINS Diesel Engine ............... 4-5
C. Low Water Level Push Button Station (Optional) - CUMMINS
Diesel Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
1. Push Button Station Layout - CUMMINS Diesel Engine .......... 4- 7
D. Control Panel - JOHN DEERE Diesel Engine ..................... 4-8
1. Control Panel Layout - JOHN DEERE Diesel Engine ............ 4-9
2. Terminal Strip Pinout - JOHN DEERE Diesel Engine ............ 4-10
II. Pre-Operating Procedure ......................................... 4-11
III. Operating
Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
A. Start-Up & Shut-Down ....................................... 4-14
1. CUMMINS Diesel Engine Start-Up .......................... 4-15
:L. JOHN DEbRE Diesel bngme Stan-up ........................
1
+-ii.
3. L-55i Oil Plunger Lubricator ................................ 4-17
4. Water Plunger Lubricator (Optional) .......................... 4-17
5. High Pressure Pump ....................................... 4-17
6. Water Inlet Bag Filter - PM3350 (Optional) .................... 4-18
7. Diesel Engine Shutdown .................................... 4-19
B. Operation Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
1. L-55i Oil Plunger Lubricator ................................ 4-19
© Copyright June, 2005 NLB Corporation
4-1