SICK RFU63 Series - Overview of all interfaces and connection options

6.3 Overview of all interfaces and connection options
NOTE
The numbering of the data interfaces (Host 1, AUX 1) in the following block diagrams
is intended to provide a better overview. The numbering is not shown in configuration
tools, e.g. in the SOPAS ET configuration software.
NOTE
The USB interface of the device is used in industrial environments only as a service
interface for temporary use (e.g. for configuration, troubleshooting). Permanent use in
operational use of the system as a host interface is not intended.
6.3.1 RFU630-131xx with integrated antenna
Service operation
The following functions can be performed via one of the five data interfaces:
AUX 1, AUX 2, AUX 3, Host 1 or Host 2
•
Configuration of the device
•
Display of the read result of the detected transponders
•
Transponder access: Reading or writing data
•
Reading diagnostics (read result in fixed output format)
For a detailed overview, see "Use of the data interfaces", page 45.
Shown here are alternatives for the AUX interface:
•
AUX port of the Ethernet interface
•
Serial data interface
•
USB interface
The USB interface must only be used temporarily as a servicing interface.
Configuration
Reading result
display
Transponder
access
Reading
diagnostics
Cable 9
Cable ß
Cable 8
Cable 6
"Power/Serial Data/CAN/I/O"
(AUX 1, Host 1)
...
...
1
2
V
S
GND
Cable 3
"Serial RS-232" (AUX 1) 4
"Ethernet" (AUX 2)
V
S
External antennas à
...
1 3
USBUSB
RFU630-
131xx
1
2
Connection
module
EthernetEthernet
7
SerialSerial
"USB" (AUX 3),
for temporary use only 5
SOPAS ETSOPAS ET
Computer
Figure 16: Block diagram RFU630-131xx with optional connection module: service operation,
e.g. display of read result
1
Supply voltage V
S
2
Connection module CDB650-204 or CDM420-0006
3
Null modem cable with two female connectors, D-Sub, 9-pin, both TxD and RxD crossed
4
Serial RS-232, alternative to USB or Ethernet AUX port
5
USB, alternative to serial RS-232 or Ethernet AUX port the USB interface must only be
used temporarily as a servicing interface.
6
Adapter cable with male connector, USB, type Micro-B and male connector, USB, type A
ELECTRICAL INSTALLATION 6
8027750//2022-12-15 | SICK O P E R A T I N G I N S T R U C T I O N S | RFU63x
41
Subject to change without notice