Terramite TSS46 - Page 93

Copyright © 2007 Terramite Corporation
7.3
WWW.TERRAMITE.COM/SAFETY
USA 1.800.428.3772
Intl. 1 .304.776.4231
Charleston, WV/USA
PARTS MANUAL
Read Operators Manual For Safety
INDEX
&
N
Neutral Switch ......................................................................................................................... 3.22
New Gauge ............................................................................................................................. 3.18
New Kit .................................................................................................................................... 3.15
O
P
Panel, Cover, Rear, Engine ............................................................................................................
Panel, Top, Engine ................................................................................................................... 3.19
Pedal, Brake ............................................................................................................................. 3.14
Pin:
1” x 2 1/8” Lg., Steering Cylinder ................................................................................... 3.13
1” x 4 1/2” Lg., Top Broom Lift ........................................................................................ 3.13
1” x 5 1/8 Lg., Broom Lift ................................................................................................ 3.13
Linch, Tow-Bar Pivot Pin ......................................................................................................
Roll 1/4” x 1 1/2” ............................................................................................................ 3.13
Tow-Bar Lift/Steering Cylinder ........................................................................................ 3.6
Tow-Bar - Lower Locking .....................................................................................................
Tow-Bar - Upper Locking .....................................................................................................
Pipe, Air Inlet ............................................................................................................................. 3.2
Pivot:
Bearing Weldment ......................................................................................................... 3.29
Bracket Weldment .......................................................................................................... 3.29
Bolt, 1/4” - 20 x 2 1/4” ..................................................................................................... 3.29
Bolt, 5/8” - 18 x 11 1/2” ................................................................................................... 3.29
Flat Washer, 5/8” ........................................................................................................... 3.29
Lock Nut, 1/4” ................................................................................................................ 3.29
Lock Washer, 5/8” .......................................................................................................... 3.29
Washer, 1 1/4” ............................................................................................................... 3.29
Plug, Drain, Water Tank .............................................................................................................. 3.3
Pre-Cleaner Assembly ............................................................................................................... 3.3
Pump, Main Transmission ................................................................................................ 3.20, 3.21
Pump, Tandem, Eaton ....................................................................................................... 3.20, 3.21
Q
R
Rod, Bellcrank Control, 4 5/8” L ................................................................................................ 3.23
Rod, Brake Lever, Plated .................................................................................................................
S
Seat ....................................................................................................................................... 3.2
Set, Arm Rest ........................................................................................................................... 3.19
Spray Bar:
6 Foot ........................................................................................................................... 3.35
8 Foot ........................................................................................................................... 3.35
Barbed Tee Water Fitting, 3/8” ....................................................................................... 3.35
Bolt, 3/8” - 16 x 1 1/4”, Zinc Plated ................................................................................. 3.35
Brass Cap ............................................................................................................. 3.26, 3.35
Brass Seal ............................................................................................................ 3.26, 3.35
Brass Water Fitting, 90
0
........................................................................................................................................................................ 3.35
Brass Water Fitting, Tee ................................................................................................ 3.35
Check Valve Strainer .............................................................................................. 3.26, 3.35
Clamp w/Screw ..................................................................................................... 3.26, 3.35
Flat Washer, 3/8” ........................................................................................................... 3.35
Lock Washer, 3/8” .......................................................................................................... 3.35
Nut ................................................................................................................................ 3.26
Spray Hose, 3/8” (6 - 10 1/2”, 2 - 4 1/2”) .................................................................................... 3.35
Spray Hose Clamp ................................................................................................................... 3.35
Spray Kit Items ......................................................................................................................... 3.26
Spring, Brake Extension, 3/4 OD ................................................................................................. 3.3
Spring, Forward/Reverse Pedal ................................................................................................ 3.20
Spring, Large, Frame to Broom ................................................................................................ 3.13
Strainer, Drain, Water Tank ......................................................................................................... 3.3
Strap, Front Holding, Water Tank ................................................................................................ 3.3
Strap, Rear Holding, Water Tank ................................................................................................ 3.3
Switch, Ignition ................................................................................................................. 3.15, 3.16
T
“T” Block .................................................................................................................................. 3.22
Tank, Water ................................................................................................................................ 3.2
Tow Bar:
Bolt 3/8” - 16 x 1 ....................................................................................................... 3.4, 3.5
Bolt 5/8 - 11 x 1.5 GR8Z ............................................................................................ 3.4, 3.5
Cable Tow Bar 16’5” ................................................................................................. 3.4, 3.5
Chain Hook Assembly ............................................................................................... 3.4, 3.5
Coupler, Adjustable, 2” Ball ...................................................................................... 3.4, 3.5
Micro Switch ............................................................................................................ 3.4, 3.5
Nut 5/8” - 11 Lock ...................................................................................................... 3.4, 3.5
Pivot Pin 6” ............................................................................................................... 3.4, 3.5
Tow Bar .................................................................................................................... 3.4, 3.5
Tow Bar Alarm Assembly .......................................................................................... 3.4, 3.5
Washer 3/8” SAE ...................................................................................................... 3.4, 3.5
Transmission: ........................................................................................................................ 3.45
Adapter Assembly Back Up Washer
Backplate Assembly Bearing
Bearing Race Bearing, Thrust
Camplate Cap Screw
Check Valve Assembly Coupler
Cover Plate Drive Shaft
Gerotor and Coupler Housing Assembly
Housing, Gasket Inner Race
Key O-Ring 3
3
/32" x
7
/8" ID, Back Plate
O-Ring in Back O-Ring,
1
/16" x
3
/8"
O-Ring,
1
/16" x 3
1
/4" O-Ring,
3
/32" x
15
/16", Outer Pintle
O-Ring, 3
3
/32" x
41
/64" O-Ring, 3
3
/32" x
7
/8"
O-Ring, Molded O-Ring, Outer Pintle
O-Ring,
1
/16" x
7
/16" Pin
Plate, Valve Plug Assembly
Poppet Filter Relief Relief Valve Assembly
Retaining Ring Rotating Kit Assembly
Rotating Rebuild Kit, Cessna Screws
Seal Cover Seal Repair Kit
Seal, Pintle Separator Plug
Shaft Seal Sleeve Cover
Spreader Spring
Spring Retainer Spring, Transmission, Relief Valve
Steel Ball Trunnion Cover
Washer
U
U-Bolt, w/Nuts “U”, 1/2NF x 31W x 6”L ...................................................................................... 3.13
V
Valve, Control, Variable, Broom RDRS-105-16 .......................................................................... 3.18
Valve, Forward/Reverse ...................................................................................................... 3.8, 3.22
Valve, Lift/Angle ................................................................................................................ 3.17, 3.18
Valve, Tow Bar ................................................................................................................................
W
Wafer, Poly, Brush ...................................................................................................................... 3.1
Wafer, Wire, Brush ..................................................................................................................... 3.1
Water Hose Connector ............................................................................................................. 3.25
Water Pump ............................................................................................................................. 3.25
Water Pump Filter .................................................................................................................... 3.25
Water Spray Orifice .......................................................................................................... 3.26, 3.35
Water System:
3/8 Crimp Clamp ........................................................................................................... 3.25
3/8 Hose x 65” ............................................................................................................... 3.25
3/8 Hose x 75” ............................................................................................................... 3.25
3/8 Mnpt x 1/2 Mnpt Step Nipple ..................................................................................... 3.25
3/8 Mnpt x 90
0
x 3/8 Barb ................................................................................................ 3.25
3/8 Plastic “T” ............................................................................................................... 3.25
1/2 Mnpt x 3x8 Barb ....................................................................................................... 3.25
90
0
Body ........................................................................................................................ 3.25
“T” Body ....................................................................................................................... 3.25
Water Tank ............................................................................................................................... 3.25
Water Tank Cap ........................................................................................................................ 3.25
Water Tank Drain Plug ............................................................................................................. 3.25
Wheel, Steering ................................................................................................................. 3.2, 3.15
X
Y
Yoke, Lever, Brake, 1/2” - 20NF ............................................................................................... 3.14
Z
Courtesy of Machine.Market